该页无缩略图
48
10mm bottom connection and half pipe disc
Bottom connection valve: VGVU-M10.....
25 m (two five single electronic control, air reset) 35E(three position five way in drain type) 23VR(two-position three-way double
normal closure, spring reset)
25B(two five-pass double electric control) 23 R (two tee double normally closed, air reset) 23VU(two position three way double
normally open, spring reset)
35C(Three-position Five-way middle-sealed type)
23 h (two tee double normally open, air reset) 23VH(two-position three-way, one normally
open and one normally closed, spring return)
35P(Three-position Five-way Medium Voltage Type)
23U(Two-position three-way, one normally open
and one normally closed, gas reset)
Half-tube valve :VGVU-S10.....
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
.7
66.5
16.8 2.7
33
16.5
80.9
14.7
5 1 3
安装螺钉
107.7 14.7
66.566.5
2.715 25.8
80.9
2.7
80.9
安装螺钉
安装螺钉2-G1/8
107.7
40.9
33
66.5
16.8 2.7
33
16.5
14.7 80.9
14.7
5 1 3
3-G1/8
安装螺钉 安装螺钉
■ The valve island is equipped with an electromagnetic valve
■ The function of the valve
49 Specification/Project Valve width Function
3/2 way Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Monostable state
Monostable state
Monostable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
5/3 way
5/3 way
5/3 way
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Spring
Spring
Spring
Air reset
Air reset
Air reset
Air reset
Air reset
5/2 way
5/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
Working medium
Compressed air
complies with
ISO8573
External leader
On the busbar
On the busbar
On the busbar
External leader
Compressed air
complies with
ISO8573
Initial position Leading gas source
Rated flow Air outlet Air outlet
Steady state L/min 1、3 、5 2、4
VGVU-M10-23R
10mm
Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
Always open
Always open
Always open
Always open
Always closed
Medium pressure
Medium Leak
Middle seal
Medium pressure
Medium Leak
Middle seal
Always closed
Always closed
180
G1/8 M5
VGVU-M10-23U 180
VGVU-M10-23H 180
VGVU-M10-23VR 150
VGVU-M10-23VU 150
VGVU-M10-23VH 150
VGVU-M10-25M — 280
VGVU-M10-25B — 280
VGVU-M10-35C 180
VGVU-M10-35P 180
VGVU-M10-35E 180
VGVU-S10-23R
10mm
180
G1/8 M5
On the valve body
VGVU-S10-23U 180
VGVU-S10-23H 180
VGVU-S10-23VR 150
VGVU-S10-23VU 150
VGVU-S10-23VH 150
VGVU-S10-25M — 280
VGVU-S10-25B — 280
VGVU-S10-35C 180
VGVU-S10-35P 180
VGVU-S10-35E 180
℃ ℃
VGVU-M10-23R
-5~60 -5~60 24±10% 1
10 0.25~0.8 0.15~0.8
VGVU-M10-23U 10 0.25~0.8 0.15~0.8
VGVU-M10-23H 10 0.25~0.8 0.15~0.8
VGVU-M10-23VR 10 0.3~0.8 -0.9~0.8
VGVU-M10-23VU 10 0.3~0.8 -0.9~0.8
VGVU-M10-23VH 10 0.3~0.8 -0.9~0.8
VGVU-M10-25M 15 0.2~0.8 -0.09~0.8
VGVU-M10-25B - 15 0.15~0.8 -0.09~0.8
VGVU-M10-35C 10 0.2~0.8 -0.09~0.8
VGVU-M10-35P 10 0.2~0.8 -0.09~0.8
VGVU-M10-35E 10 0.2~0.8 -0.09~0.8
VGVU-S10-23R
-5~60 -5~60 24±10% 1
10 0.25~0.8 0.15~0.8
VGVU-S10-23U 10 0.25~0.8 0.15~0.8
VGVU-S10-23H 10 0.25~0.8 0.15~0.8
VGVU-S10-23VR 10 0.3~0.8 -0.09~0.8
VGVU-S10-23VU 10 0.3~0.8 -0.09~0.8
VGVU-S10-23VH 10 0.3~0.8 -0.09~0.8
VGVU-S10-25M 15 0.2~0.8 -0.09~0.8
VGVU-S10-25B - 15 0.15~0.8 -0.09~0.8
VGVU-S10-35C 10 0.2~0.8 -0.09~0.8
VGVU-S10-35P 10 0.2~0.8 -0.09~0.8
VGVU-S10-35E 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VGVU-10mm valve plate
VGVT Series
Note: When the valve island of Specification 10 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.4Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
50
Installation screw Installation screw Installation screw Installation screw
Installation screw
VGVU-M10 bottom-connected valve VGVU-S10 half-tube valve
VGVU-M10-T bottom-connected blind plate
/VGVU-S10-T half-tube blind plate
VGVU-M10-X bottom-mounted air source board
/VGVU-S10-X half-tube air source board
89.8
33
41
48
14.7 63
12.5 17.8 3
2-M5
安装螺钉 安装螺钉
10.3
33
41
89.8
14.7
48
60 3
安装螺钉 安装螺钉
10.3
89.4
35.6
30.3
10
3
48
27.5
15
33.4 24.5
20 16 6.3
5
L2
L1
16 18.6
92.5
Φ4.3
4-通孔
4.5
57.3
2-M5
15
18.9
24.5
5
33.4
20 16 2-M5
16 18.6
L2
L1
Φ4.3
4-通孔
92.5
4.5
57.3
10.5
10.5
89.8
33
41
48
14.7 63
12.5 17.8 3
2-M5
10.3
33
41
89.8
14.7
48
60 3
安装螺钉 安装螺钉
10.3
89.4
35.6
30.3
10
3
安装螺钉 48 安装螺钉
89.8
33
41
48
14.7 63
12.5 17.8 3
2-M5
安装螺钉 安装螺钉
10.3
33
41
89.8
14.7
48
60 3
10.3
89.4
35.6
30.3
10
3
安装螺钉 48 安装螺钉
L216 18.6
92.5
Φ4.3
4-通孔
4.5
57.3
15
18.9
24.5
5
33.4
20 16 2-M5
16 18.6
L
LΦ4.3
4-通孔
92.5
4.5
57.3
10.5
10.5
■ The external dimensions of a 10mm valve plate
Installation screw Installation screw
107.7 14.7
33
40.9
66.5
2.7 14.7
15 25.8
80.9
安装螺钉 安装螺钉
2-G1/8
40.9
33
3340.9
5
19
4.5
6
12
15
17
54.8
10.
2
7
6.
4
5
2.5
53.3
12
两侧2-M5
两侧3-G1/8
4.5
10.
2
7
6.
4
5
2.5
53.3
54.8
6
12
15
17
12
两侧3-G1/8
两侧2-M5
M5
52.5 B1
27.5
15
33.4 24.5
20 16 6.3
10.5
5
19
B1
5
L2
L1
16 18.6
92.5
Φ4.3
4-通孔
4.5 4.5
57.3 L3
6
12
15
17
54.8
10.
2
7
6.
4
5
2.5
53.3
12
2-M5
两侧2-M5
两侧3-G1/8
15
18.9
24.5
5
33.4
20 16 2-M5
16 18.6
L2
L1
Φ4.3
4-通孔
92.5
4.5 4.5
57.3
10.5
L3
10.5
10.
2
7
6.
4
5
2.5
53.3
54.8
6
12
15
17
12
两侧3-G1/8
两侧2-M5
M5
4.5
3
654.8
10.
2
7
6.
4
5
2.5
53.3
12
两侧2-M5
两侧3-G1/8
4.5
L3
10.
2
7
6.
4
5
2.5
53.3
54.8
6
12
15
17
12
两侧3-G1/8
两侧2-M5
51 25M (two five single electronic control, air reset) 35E(three position five way in drain type) 23VR (two tee double normally closed, spring return)
25B(two five-pass double electric control) 23R (two tee double normally closed, air reset) 23VU (two tee double normally open, spring return)
35C(Three-position Five-way middle-sealed type)
35P(Three-position Five-way Medium Voltage Type) 23U(Two-position three-way, one normally open
and one normally closed, gas reset)
23H (two tee double normally open, air reset) 23VH(two-position tee, one normally open,
one normally closed, spring reset)
14mm bottom connection and half pipe disc
Bottom connection valve: VGVU-M14..... Half tube valve :VGVU-S14.....
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
107.7
66.5
16.8 2.7
33
16.5
80.9
14.7
5 1 3
3-G1/8
钉 安装螺钉
107.7 14.7
66.5
2.7 14.7
15 25.8
80.9
2.7
14.7 80.9
安装螺钉 安装螺钉
2-G1/8
107.7
40.9
33
66.5
16.8 2.7
33
16.5
14.7 80.9
14.7
5 1 3
3-G1/8
安装螺钉 安装螺钉
■ Valve island with solenoid valve
■ Function of valve
VGVT Series
122.6
33
40.9
18.7 122.6
33
40.9
52
L/min 1、3 、5 2、4
VGVU-M14-23R
14mm
520
G1/4 G1/8
VGVU-M14-23U 520
VGVU-M14-23H 520
VGVU-M14-23VR 500
VGVU-M14-23VU 500
VGVU-M14-23VH 500
VGVU-M14-25M — 530
VGVU-M14-25B — 530
VGVU-M14-35C 500
VGVU-M14-35P 530
VGVU-M14-35E 500
VGVU-S14-23R
14mm
520
G1/4 G1/8
VGVU-S14-23U 520
VGVU-S14-23H 520
VGVU-S14-23VR 500
VGVU-S14-23VU 500
VGVU-S14-23VH 500
VGVU-S14-25M — 530
VGVU-S14-25B — 530
VGVU-S14-35C 500
VGVU-S14-35P 530
VGVU-S14-35E 500
VGVU-M14-23R
-5~60 -5~60 24±10% 1
10 0.25~0.8 0.15~0.8
VGVU-M14-23U 10 0.25~0.8 0.15~0.8
VGVU-M14-23H 10 0.25~0.8 0.15~0.8
VGVU-M14-23VR 10 0.3~0.8 -0.9~0.8
VGVU-M14-23VU 10 0.3~0.8 -0.9~0.8
VGVU-M14-23VH 10 0.3~0.8 -0.9~0.8
VGVU-M14-25M 15 0.2~0.8 -0.09~0.8
VGVU-M14-25B - 15 0.15~0.8 -0.09~0.8
VGVU-M14-35C 10 0.2~0.8 -0.09~0.8
VGVU-M14-35P 10 0.2~0.8 -0.09~0.8
VGVU-M14-35E 10 0.2~0.8 -0.09~0.8
VGVU-S14-23R
-5~60 -5~60 24±10% 1
10 0.25~0.8 0.15~0.8
VGVU-S14-23U 10 0.25~0.8 0.15~0.8
VGVU-S14-23H 10 0.25~0.8 0.15~0.8
VGVU-S14-23VR 10 0.3~0.8 -0.09~0.8
VGVU-S14-23VU 10 0.3~0.8 -0.09~0.8
VGVU-S14-23VH 10 0.3~0.8 -0.09~0.8
VGVU-S14-25M 15 0.2~0.8 -0.09~0.8
VGVU-S14-25B - 15 0.15~0.8 -0.09~0.8
VGVU-S14-35C 10 0.2~0.8 -0.09~0.8
VGVU-S14-35P 10 0.2~0.8 -0.09~0.8
VGVU-S14-35E 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VGVU-14mm valve plate
Note: When the valve island of Specification 14 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.4Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
Specification/Project Valve width Function
3/2 way Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Monostable state
Monostable state
Monostable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
5/3 way
5/3 way
5/3 way
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Spring
Spring
Spring
Air reset
Air reset
Air reset
Air reset
Air reset
5/2 way
5/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
Working medium
Compressed air
complies with
ISO8573
External leader
On the busbar On the busbar
On the busbar On the busbar
External leader
Compressed air
complies with
ISO8573
Initial position Leading gas source
Rated flow Air outlet Air outlet
Steady state
Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
Always open
Always open
Always open
Always open
Always closed
Medium pressure
Medium Leak
Middle seal
Medium pressure
Medium Leak
Middle seal
Always closed
Always closed
℃ ℃ Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
18.7
54.5 B1
27.5
15 10
13.8
34.6 42.5
10
33
122.6
33
40.9
18.7 122.6
33
40.9
18.7
53 VGVU-M14 bottom-connected valve
VGVU-M14-X bottom-mounted air source board
/VGVU-S14-X half-tube air source board
VGVU-M14-T bottom-connected blind plate
/VGVU-S14-T half-tube blind plate
VGVU-S14 half-tube valve
107.3 14.2
66.5
2.7
37.3
30.3
Installation screw
Installation screw
Installation screw Installation screw Installation screw Installation screw
Installation screw Installation screw
■ The external dimensions of a ��mm valve plate
107.7 14.7
33
40.9
66.5
2.7 14.7
15 25.8
80.9
安装螺钉 安装螺钉
2-G1/8
1040.9
33
14.7 3-G1/8
安装螺钉 33
40.9
14.7
14.7 安装螺钉 安装螺钉 VGVT Series
54
18mm bottom-mounted and half-tube valve plates
Bottom connection valve: VGVU-M18.....
25M(two five single electronic control, air reset) 35E(Three-position Five-way Medium Drain Type) 23VR(two tee double normally closed, spring return)
25B(two five-pass double electric control) 23R(Two-position three-way double normally closed, gas reset) 23VU(Two-position three-way double normally open, spring return)
35C(Three-position Five-way middle-sealed type) 23H(two-position three-way double-open, gas reset)
35P(Three-position Five-way Medium Voltage Type) 23U(Two-position three-way, one normally open
and one normally closed, gas reset)
23VH(two-position three-way, one normally open
and one normally closed, spring return)
Half tube valve :VGVU-S18.....
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
14 14
14
12
10(12)
10(12)
12/14 82/84 1 5
14/10 82/84 1 5
10/(14) 82/84 1 5
10/(14)
14
14
14
14
84
84
4 12
12
2
4 2
4 2 12
14 4 2 12
4 2
4 2
3
3
3
4 2
4 2
5 1 3
5 1 3
14 84 5 1 3
14 84 5 1 3
14 84 5 1 3
07.7
66.5
16.8 2.7
33
16.5
80.9
14.7
5 1 3
安装螺钉
107.7 14.7
66.5
2.715 25.8
80.9
2.7
80.9
安装螺钉
安装螺钉2-G1/8
107.7
40.9
33
66.5
16.8 2.7
33
16.5
14.7 80.9
14.7
5 1 3
3-G1/8
安装螺钉 安装螺钉
■ Valve island with solenoid valve
■ Function of valve
55 122.6
33
40.9
82
2-G1/4
14.7 95.8
21 30.5 3
1安装螺钉 安装螺钉
15
18.
3
9
4.6
13.8
10
27
10
42.5
M5
G1/8
B3
26 37 5 5
62.7
19
B2
131
Φ5.5
4-通孔
122.6
33
40.9
82
2-G1/4
14.7 95.8
21 30.5 3
18.7
安装螺钉 安装螺钉
33
40.9
14.7 安装螺钉 15
18.
3
9
4.6
13.8
10
27
10
42.5
M5
G1/8
B3
26 37 5 5
62.7
19
B2
131
Φ5.5
4-通孔
14.5
24.5
27
35
24.7
49.5
76
79
92
18.5 G3/8
2-G1/8
VGVU-M18-23R
14mm
1100
G3/8 G1/4
VGVU-M18-23U 1100
VGVU-M18-23H 1100
VGVU-M18-23VR 1000
VGVU-M18-23VU 1000
VGVU-M18-23VH 1000
VGVU-M18-25M — 1200
VGVU-M18-25B — 1200
VGVU-M18-35C 1000
VGVU-M18-35P 1000
VGVU-M18-35E 1000
VGVU-S18-23R
14mm
1100
G3/8 G1/4
VGVU-S18-23U 1100
VGVU-S18-23H 1100
VGVU-S18-23VR 1000
VGVU-S18-23VU 1000
VGVU-S18-23VH 1000
VGVU-S18-25M — 1200
VGVU-S18-25B — 1200
VGVU-S18-35C 1000
VGVU-S18-35P 1000
VGVU-S18-35E 1000
VGVU-M18-23R
-5~60 -5~60 24±10% 1
10 0.25~0.8 0.15~0.8
VGVU-M18-23U 10 0.25~0.8 0.15~0.8
VGVU-M18-23H 10 0.25~0.8 0.15~0.8
VGVU-M18-23VR 10 0.3~0.8 -0.9~0.8
VGVU-M18-23VU 10 0.3~0.8 -0.9~0.8
VGVU-M18-23VH 10 0.3~0.8 -0.9~0.8
VGVU-M18-25M 15 0.2~0.8 -0.09~0.8
VGVU-M18-25B - 15 0.15~0.8 -0.09~0.8
VGVU-M18-35C 10 0.2~0.8 -0.09~0.8
VGVU-M18-35P 10 0.2~0.8 -0.09~0.8
VGVU-M18-35E 10 0.2~0.8 -0.09~0.8
VGVU-S18-23R
-5~60 -5~60 24±10% 1
10 0.25~0.8 0.15~0.8
VGVU-S18-23U 10 0.25~0.8 0.15~0.8
VGVU-S18-23H 10 0.25~0.8 0.15~0.8
VGVU-S18-23VR 10 0.3~0.8 -0.09~0.8
VGVU-S18-23VU 10 0.3~0.8 -0.09~0.8
VGVU-S18-23VH 10 0.3~0.8 -0.09~0.8
VGVU-S18-25M 15 0.2~0.8 -0.09~0.8
VGVU-S18-25B - 15 0.15~0.8 -0.09~0.8
VGVU-S18-35C 10 0.2~0.8 -0.09~0.8
VGVU-S18-35P 10 0.2~0.8 -0.09~0.8
VGVU-S18-35E 10 0.2~0.8 -0.09~0.8
VGVT Series
Specification/Project Valve width Function Working medium Initial position Leading gas source
Rated flow Air outlet Air outlet
Steady state L/min 1、3 、5 2、4
3/2 way Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Monostable state
Monostable state
Monostable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
5/3 way
5/3 way
5/3 way
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Spring
Spring
Spring
Air reset
Air reset
Air reset
Air reset
Air reset
5/2 way
5/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
On the busbar On the busbar
On the busbar On the busbar
External leader
External leader
Compressed air
complies with
ISO8573
Compressed air
complies with
ISO8573
Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
Always open
Always open
Always open
Always open
Always closed
Medium pressure
Medium Leak
Middle seal
Medium pressure
Medium Leak
Middle seal
Always closed
Always closed
℃ ℃
Note: When the valve island of Specification 18 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.4Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
Technical parameters of VGVU-��mm valve plate
56
VGVU-M18 bottom-connected valve plate VGVU-S18 half-tube valve plate
VGVU-M18-X bottom-mounted air source board
/VGVU-S18-X half-tube air source board
VGVU-M18-T bottom-connected blind plate
/VGVU-S18-T half-tube blind plate
122.6
33
40.9
82
2-G1/4
14.7 95.8
21 30.5 3
18.7
33
40.9
1
安装螺15
18.
3
9
4.6
13.8
10
27
10
42.5
M5
G1/8
B3
26 37 5 5
62.7
19
B2
131
Φ5.5
4-通孔
14.5
24.5
27
35
24.7
49.5
76
79
92
18.5 G2-G1/8 18.7
122.6
33
40.9
82
3
14.7 95.8
18.7
122
30.5
37.3
82
3
18
10
安装螺钉 安装螺钉
54.5 B1
27.5
15 10
13.8
34.6 42.5
10
33
10
27
60.5
6 19
B1
L2
L1
37 26
131
Φ5.5
4-通孔
5 5
62.7 L3
19
14.5
24.5
27
35
18.5
24.7
49.5
76
79
92
3-G
2-G1/8
14.5
24.5
27
35
24.7
49.5
76
79
92
18.5 G3/8
2-G1/8
G1/4
122.6
82
3
95.8
18.7
安装螺钉
122
30.5
37.3
82
3
18
10
54.5 B1
27.5
15 10
13.8
34.6 42.5
10
33
10
27
60.5
6 19
B1
L2
L1
37 26
131
Φ5.5
4-通孔
5 5
62.7 L3
19
14.5
24.5
27
35
18.5
24.7
49.5
76
79
92
3-G3/8
2-G1/8
G1/4
Installation screw
Installation screw Installation screw
Installation screw Installation screw Installation screw Installation screw
The external dimensions of a ��mm valve plate
122.6
82
3
95.8
18.7
安装螺钉
122
30.5
37.3
82
3
18
10
安装螺钉 安装螺钉
54.5 B1
27.5
15 10
13.8
34.6 42.5
10
33
10
27
60.5
6 19
B1
L2
L1
37 26
131
Φ5.5
4-通孔
5 5
62.7 L3
19
14.5
24.5
27
35
18.5
24.7
49.5
76
79
92
3-G3/8
2-G1/8
G1/4
57 ■ Order code for individual ordering of busbar assemblies
89.8
33
41
48
14.7 63
12.5 17.8 3
2-M5
安装螺钉 安装螺钉
10.3
33
41
89.8
14.7
48
60 3
安装螺钉 安装螺钉
10.3
89.4 10
VGVA S 14 4 Z Q10 U Q6S S25
Series: Valve Island
Type of air outlet
S: Air out of the valve body
M: Side vent of confluence plate
D: Vent at the bottom of the bus plate
Valve width
10: Valve width 10mm
14: Valve width 14mm
18: Valve width 18mm
Blank: Internal lead
Z: External leader
Valve bit number
4:4 valve positions
5:5 valve positions
6:6 valve positions
7:7 valve positions
8:8 valve positions
9:9 valve positions
10:10 valve positions
12:12 valve positions
16:16 valve positions
20:20 valve positions
24:24 valve positions
Gas source interface
Blank: No connector installed
Q6: Quick connector 6mm
Q8: Quick connector 8mm
Q10: Quick connector 10mm
Q12: Quick connector 12mm
Q16: Quick connector 16mm
Note
Q6, Q8 suitable for valve width 10mm
Q10, Q12 suitable for valve width 14mm
Q12, Q16 suitable for valve width 18mm
Valve port (in valve position)
Blank: No connector installed
Q4S: Quick connector 4mm
Q6S: Quick connector 6mm
Q8S: Quick connector 8mm
Note
Q4, Q6 suitable for valve width 10mm
Q6, Q8 suitable for valve width 14mm
Q6, Q8, Q10 are suitable for valve width 18mm
Blank: Installed on both sides
L: Install on the left side
R: Install on the right side
Blank: Insert directly
A: L-shaped elbow
Blank: Install on both sides
L: Install on the left side
R: Install on the right side
Communication protocol
S25:Sub-D 25 pins
S44:Sub-D 44 pins
L:IO-Link
CO:CANopen
EC:EtherCAT
EP:EtherNet
PN:ProfiNet
BA: CIEBS
Blank: No muffler
U: Resin muffler
N: Metal muffler
VGVT Series
For example, if a semi-tube manifold needs to be ordered separately, with a valve width of 14mm, an external pilot air source, a digit of 5, and no joints or
mufflers installed, the code should be written as: VGVA-S14-5-Z
Note: When the number of valve positions is ≥8, it is recommended to choose air intake on both sides of the manifold to ensure sufficient air pressure
58
Model Number of valves L1 L2 L3 B1
VGVA-M10
4 103 94 31.5 31.5
5 113.5 104.5 42 42
6 124 115 52.5 52.5
7 134.5 125.5 63 63
8 145 136 73.5 73.5
9 155.5 146.5 84 84
10 166 157 94.5 94.5
12 187 178 115.5 115.5
16 229 220 157.5 157.5
20 271 262 199.5 199.5
24 313 304 241.5 241.5
52.5 B1
27.5
15
33.4 24.5
20 16 6.3
10.5
5
19
B1
5
L2
L1
16 18.6
92.5
4.5 4.5
57.3 L3
6
12
15
17
54.8
10.
2
7
6.
4
5
2.5
53.3
12
2-M5
Both sides 2-M5
Both sides 3-G1/8
15
18.9
24.5
5
33.4
20 16 2-M5
L2
L1
10.5
6
12
15
17
两侧
M5
■ Side outlet bus (with valve plate) VGVA-M�� dimensions
Through hole
3 Φ4. 4-
48
14.7 63
12.5 17.8 3
2-M5
安装螺钉 安装螺钉
33
41
89.8
14.7
48
60 3
安装螺钉 安装螺钉
10.3
89.4
35.6
30.3
10
3
安装螺钉 48 安装螺钉
59 Both sides
Both sides
L1 L2 L3
VGVA-S10
4 103 94 31.5
5 113.5 104.5 42
6 124 115 52.5
7 134.5 125.5 63
8 145 136 73.5
9 155.5 146.5 84
10 166 157 94.5
12 187 178 115.5
16 229 220 157.5
20 271 262 199.5
24 313 304 241.5
1 4.5 4.5
57.3 L3
1012
两侧3-G1/8
15
18.9
24.5
5
33.4
20 16 2-M5
16 18.6
L2
L1
92.5
4.5 4.5
57.3
10.5
L3
10.5
10.
2
7
6.
4
5
2.5
53.3
54.8
6
12
15
17
12
3-G1/8
2-M5
■ Valve vent bus (with disc) VGVA-S�� outline dimensions
VGVT Series
Through hole
3 Φ4. 4-
Model Number of valves
60
L L1 L2 L3 B1 B2 B3
VGVA-D10
4 108 82 - - 31.5 31.5 99
5 118.5 92.5 - - 42 42 109.5
6 129 103 - - 52.5 52.5 120
7 139.5 113.5 - - 63 63 130.5
8 150 124 - - 73.5 73.5 141
9 160.5 134.5 - 67.25 84 84 151.5
10 171 145 - 72.5 94.5 94.5 162
12 192 166 - 83 115.5 115.5 183
16 234 208 - 104 157.5 157.5 225
20 276 250 - 125 199.5 199.5 267
24 318 292 192 100 241.5 241.5 309
■ Bottom outlet bus (with valve plate) VGVA-D�� dimensions
Model Number of
valves
Through hole
3 Φ4. 4-
Both sides2-M5
Both sides3-G1/8
M4 thread depth 7
61 L1 L2 L3 B1
VGVA-M14
4 128 118 48 48
5 144 134 64 64
6 160 150 80 80
7 176 166 96 96
8 192 182 112 112
9 208 198 128 128
10 224 214 144 144
12 256 246 176 176
16 320 310 240 240
20 384 374 304 304
24 448 438 368 368
VGVT Series
Model Number of valves Side outlet bus (with valve plate) VGVA-M�� dimensions Both sides 3-G1/4
Both sides 2 -M 5
Through hole
5 Φ4. 4-
62
L1 L2 L3
VGVA-S14
4 128 118 48
5 144 134 64
6 160 150 80
7 176 166 96
8 192 182 112
9 208 198 128
10 224 214 144
12 256 246 176
16 320 310 240
20 384 374 304
24 448 438 368
B3
5 5
60.6 B2
16
26 20
Φ4.5
4-通孔
13.3
18.3
23.8
28.8
15.8
16.5
35.5
56.5
59.5
69.25
两侧2-M5
两侧3-G1/4
5
10
15
18.
3
9
4.6 33.8
10
25.5
2-M5
110
Model Number of valves
Valve vent bus (with disc) VGVA-S�� External dimensions
Both sides 3-G1/4
Both sides 2 -M 5
Through hole
5 Φ4. 4-
63 B3
5 5
60.6 B2
16
26 20
Φ4.5 4-
13.3
18.3
23.8
28.8
15.8
16.5
35.5
56.5
59.5
69.25
2-M5
3-G1/4
5
10
15
18.
3
9
4.6 33.8
10
25.5
2-M5
110
L L1 L2 L3 L4 B3 B2 B1
VGVA-D14
4 128 116 - - - 118 48 48
5 144 132 - - - 134 64 64
6 16 148 - - - 150 80 80
7 176 164 - - - 166 96 96
8 192 180 - - 90 182 112 112
9 208 196 - - 98 198 128 128
10 224 212 - - 106 214 144 144
12 256 244 - 162 82 246 176 176
16 320 308 - 204 104 310 240 240
20 384 372 279 186 93 374 304 304
24 448 436 327 218 109 438 368 368
122.6
33
40.9
82
2-G1/4
14.7 95.8
21 30.5 3
18.7
安装螺钉 安装螺钉
122.6
33
40.9
82
14.7 95.8
安装螺钉 30.5
37.3
10
15
18.
3
9
4.6
13.8
10
27
10
42.5
M5
G1/8
B3
26 37 5 5
62.7
19
B2
131
Φ5.5
4-通孔
14.5
24.5
27
35
24.7
49.5
76
79
92
18.5 G3/8
2-G1/8
VGVT Series
Bottom outlet bus (with valve plate) VGVA-D�� dimensions Through hole
Model Number of
valves
Both sides
Both sides
64
L1 L2 L3 B1
VGVA-M18
4 139.5 129.5 57 57
5 158.5 148.5 76 76
6 177.5 167.5 95 95
7 196.5 186.5 114 114
8 215.5 205.5 133 133
9 234.5 224.5 152 152
10 253.5 243.5 171 171
12 291.5 281.5 209 209
16 367.5 357.5 285 285
20 443.5 433.5 361 361
24 519.5 509.5 437 437
3
18.7
安装螺钉
122
82
3
18
安装螺钉 安装螺钉
54.5 B1
27.5
15 10
13.8
34.6 42.5
10
33
10
27
60.5
6 19
B1
L2
L1
37 26
131
Φ5.5
4-
5 5
62.7 L3
19
14.5
24.5
27
35
18.5
24.7
49.5
76
79
92
3-G3/8
2-G1/8
G1/4
Side outlet bus (with valve plate) VGVA-M�� dimensions
Model Number of valves
Through hole
Φ 3.2
2-
10.3
2 -M 5
Φ 2.4
2-
24
12
27
3-M5
27
4.4
电 气 接 口
68.3
80.8
65 L1 L2 L3
VGVA-S18
4 139.5 129.5 57
5 158.5 148.5 76
6 177.5 167.5 95
7 196.5 186.5 114
8 215.5 205.5 133
9 234.5 224.5 152
10 253.5 243.5 171
12 291.5 281.5 209
16 367.5 357.5 285
20 443.5 433.5 361
24 519.5 509.5 437
2-G1/4
14.7 95.8
21 30.5 3 314.7 95.8
30.5
37.3
10
安15
18.
3
9
4.6
13.8
10
27
10
42.5
M5
G1/8
B3
26 37 5 5
62.7
19
B2
131
14.5
24.5
27
35
24.7
49.5
76
79
92
18.5 G3/8
2-G1/8
Valve vent bus (with disc) VGVA-S�� External dimensions
■ VGVT Series
Model Number of valves
Φ5.5
4-
Through hole
33.4
Φ 2.4
2 -
2 -M 5
8
1 .5
M3外先导接口
66
3
122
82
3
18
安装螺钉 安装螺钉
L2
L137 26
131
Φ5.5
4-通
5 5
62.7 L3
19
14.5
24.518.5
24.7
49.5
76
79
92
3-G3/8
2-G1/8
Bottom outlet bus (with valve plate) VGVA-D�� dimensions
L L1 L2 L3 L4 L5 B3 B2 B1
VGVA-D18
4 139.5 113.5 - - - - 129.5 57 57
5 158.5 132.5 - - - - 148.5 76 76
6 177.5 151.5 - - - 75.8 167.5 95 95
7 196.5 170.5 - - - 85.3 186.5 114 114
8 215.5 189.5 - - - 94.8 205.5 133 133
9 234.5 208.5 - - - 104.3 224.5 152 152
10 253.5 227.5 - - - 113.8 243.5 171 171
12 291.5 265.5 - - 165.5 100 281.5 209 209
16 367.5 341.5 - - 170.8 100 357.5 285 285
20 443.5 417.5 - 317.5 208.8 100 433.5 361 361
24 519.5 493.5 393.5 293.5 200 100 509.5 437 437
2-G1/4
14.7 95.8
21 30.5 3 3
14.7 95.8
30.5
37.3
10
安装螺钉
15
18.
3
9
4.6
13.8
10
27
10
42.5
M5
G1/8
B3
26 37 5 5
62.7
19
B2
131
14.5
24.5
27
35
24.7
49.5
76
79
92
18.5 G3/8
2-G1/8
■
Model Number of
valves
Φ5.5
4-
Through hole
67 M1-25-SUB Main technical parameters
M1-25-SUB
25
Sub-D plug
12 dual electronic control or
24 single electronic control
IP67
Each pin on a multi-pin plug can drive one electromagnetic coil, and a 25-pin plug can drive up to 24
electromagnetic coils. This means that with dual electronic control, up to 12 valve positions can be
configured, and with single electronic control, up to 24 valve positions can be configured. A double
electrically controlled solenoid valve occupies one valve position and two pins on a multi-pin plug.
VP valve position
90.5
41.9 18.9
M1-25 (V20)
1 VP0 14 VP0 14 VP0 14 VP0 14
2 VP0 12 VP0 12 VP0 12 VP23 14
3 VP1 14 VP1 14 VP1 14 VP1 14
4 VP1 12 VP1 12 VP1 12 VP22 14
5 VP2 14 VP2 14 VP2 14 VP2 14
6 VP2 12 VP2 12 VP2 12 VP21 14
7 VP3 14 VP3 14 VP3 14 VP3 14
8 VP3 12 VP3 12 VP3 12 VP20 14
9 VP4 14 VP4 14 VP4 14 VP4 14
10 VP4 12 VP4 12 VP19 14 VP19 14
11 VP5 14 VP5 14 VP5 14 VP5 14
12 VP5 12 VP5 12 VP18 14 VP18 14
13 VP6 14 VP6 14 VP6 14 VP6 14
14 VP6 12 VP6 12 VP17 14 VP17 14
15 VP7 14 VP7 14 VP7 14 VP7 14
16 VP7 12 VP7 12 VP16 14 VP16 14
17 VP8 14 VP8 14 VP8 14 VP8 14
18 VP8 12 VP15 14 VP15 14 VP15 14
19 VP9 14 VP9 14 VP9 14 VP9 14
20 VP9 12 VP14 14 VP14 14 VP14 14
21 VP10 14 VP10 14 VP10 14 VP10 14
22 VP10 12 VP13 14 VP13 14 VP13 14
23 VP11 14 VP11 14 VP11 14 VP11 14
24 VP11 12 VP12 14 VP12 14 VP12 14
25 Com Com Com Com Com
Pin distribution - Sub-D plug, 25 pins Note
90.5
41.9 18.9 42.5
91.2
27
■ �� pin electrical control box ■ Multi-pin interface technical parameters 42.5
91.2
27
VGVT Series
Model
Stitch
12X dual electronic control 8X dual electronic control,
8X single electronic control
The gray area indicates that double electric air valves can be
used, while the white area indicates that only single electric
control valves can be used
4X dual electronic control,
16X single electronic control 24X single electronic control
Number of needles
Electrical connection
Maximum valve number
Protection class meets EN60529
68
M1-44-SUB
Sub-D plug
18 dual electronic control or
6 single electronic control
M1-44-SUB
44
IP67
Main technical parameters
M1-44(V12)
1 VP0 14 17 VP8 14 33 VP16 14
2 VP0 12 18 VP8 12 34 VP16 12
3 VP1 14 19 VP9 14 35 VP17 14
4 VP1 12 20 VP9 12 36 VP17 12
5 VP2 14 21 VP10 14 37 VP18 14
6 VP2 12 22 VP10 12 38 VP19 14
7 VP3 14 23 VP11 14 39 VP20 14
8 VP3 12 24 VP11 12 40 VP21 14
9 VP4 14 25 VP12 14 41 VP22 14
10 VP4 12 26 VP12 12 42 VP23 14
11 VP5 14 27 VP13 14 43
com
12 VP5 12 28 VP13 12 44
13 VP6 14 29 VP14 14
14 VP6 12 30 VP14 12
15 VP7 14 31 VP15 14
16 VP7 12 32 VP15 12
Each pin on a multi-pin plug can drive one electromagnetic coil, and a 44-pin plug can drive up to 24
electromagnetic coils. This means that if all dual electronic control is used, up to 18 valve positions can be
configured +6 single electronic control valves can be configured. If all single electronic control is used, up
to 24 valve positions can only be configured. A double electrically controlled solenoid valve occupies one
valve position and two pins on a multi-pin plug.
Pin distribution - Sub-D plug, 44 pins
90.5
41.9 18.9
■ �� pin electrical control box
■ Multi-pin interface technical parameters
90.5
41.9 1518.9
Stitch Stitch Stitch
18X dual electronic control,
6X single electronic control
18X dual electronic control,
6X single electronic control
18X dual electronic control,
6X single electronic control
Main technical parameters
Model
Number of needles
Electrical connection
Maximum valve number
Protection class meets EN60529
69 Pin allocation
Parts list
Pin configuration
Change of socket position
Model Stitch Cable length S1WA25-K-2.5 25 needles 2.5 meters long cable
5 meters long cable
1:25 needle SUU-D female head
2: Cable
3: Screw
4: Shell
5: Cable lock nut
S1WA25-K-5 25 needles
25×0.34
10
125
60
IP65
-5~80
Compliant with RoHS standards
Cable structure (mm ²)
Cable diameter D (mm)
Minimum bending radius R (mm)
Free length at the end X (mm)
Protection grade
Operating temperature: ℃
Free of harmful substances
Cable materia
Sheath color
Standard citation
SRPVC/FRPVC
RAL7001
UL758-2464
Color of the line Stitch
White
Brown
Green
Yellow
Grey
Pink
Blue
Red
Black
Purple
Gray - Pink
Red - Blue
Green - White
Brownish green
Yellow - White
Brown - Yellow
Gray - White
Brown - Gray
White - Pink
Brown - Pink
Blue - White
Brown - Blue
Red - White
Brown - Red
Black and White
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
S1WA25-K-…
电缆结构 （m㎡) 25x0.34
电缆直径 D(mm) 10± 0.3
最小弯曲半径 R(mm) 125
端部自由长度 X(mm) 60
防护等级 IP65
工作温度 (℃) ﹣5℃…+80℃
无有害物质 符合RoHS 标准
电缆材料 SRPVC/FRPVC
护套颜色 RAL7001
规范引用 UL758-2464
线的颜色 针脚白 1
棕 2
緑 3
黄 4
灰 5
粉 6
蓝 7
红 8
黑 9
紫 10
灰-粉 11
红-蓝 12
绿-白 13
棕-绿 14
黄-白 15
棕-黄 16
灰-白 17
棕-灰 18
白-粉 19
棕-粉 20
蓝-白 21
棕-蓝 22
红-白 23
棕-红 24
黑白 25
1: 25针SUU-D母头
2：电缆
3：螺钉
4：外壳
5：电缆锁紧螺母
1）零件清单
• 松开螺母5
• 用螺丝刀从A、B两
处将母头1 推出
• 推电缆2直至母头1
离开外壳4
• 将电缆2和母头翻
转180°
• 将母头1和电缆2推
入外壳4
• 推母头进入A、B两
处卡槽内
• 拧紧螺母5
4）技术参数 5）针脚分配
● Loosen the nut 5
● Use A screwdriver to push out
the female head 1 from points A
and B
● Push Cable 2 until the female
connector 1 leaves the casing 4
●Flip Cable 2 and the female
connector 180°
●Push female head 1 and cable 2
into housing 4
●Push the female head into the
two slots A and B
● Tighten the nut 5
■ Technical parameters ■ 25 pin connection cable VGVT Series
70
Parts list
Pin configuration
Change of socket position
Pin allocation
Cable length
5 meters long cable
3 meters long cable
1.5 meters long cable
Stitch
S1WA44-K-1.5 44 needles
S1WA44-K-3 44 needles
S1WA44-K-5 44 needles
Compliant with RoHS standards
44×0.16
12
135
60
IP65
-5~80
FRPVC
RAL7001
UL758-2464
White (1 black long strip)
White (1 short black block)
White (2 short black blocks)
White (3 short black blocks)
White (4 short black blocks)
White (1 long red strip)
White (1 short red block)
White (2 short red blocks)
White (3 short red blocks)
White (4 short red blocks)
Grey (1 black long strip)
Grey (1 short black block)
Grey (2 short black blocks)
Grey (3 short black blocks)
Grey (4 short black blocks)
Grey (1 long red strip)
Grey (1 short red block)
Grey (2 short red blocks)
Grey (3 short red blocks)
Grey (4 short red blocks)
Yellow (1 black long strip)
Yellow (1 short black block)
Yellow (2 short black pieces)
Yellow (3 short black blocks)
Yellow (4 short black pieces)
Yellow (1 long red strip)
Yellow (1 short red block
Yellow (2 short red pieces)
Yellow (3 short red blocks)
Yellow (4 short red blocks)
Red (1 black long strip)
Red (1 short black block)
Red (2 short black pieces)
Red (3 short black blocks)
Red (4 short black blocks)
Red (1 long red strip)
Red (1 short red piece)
Red (2 short red pieces)
Red (3 short red pieces)
Red (4 short red pieces)
Purple (1 short black piece)
Purple (2 short black pieces)
Purple (3 short black pieces)
Four short pieces of purple (black)
Stitch
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
Stitch
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
脚
S1WA25-K-…
电缆结构 （m㎡) 25x0.34
电缆直径 D(mm) 10± 0.3
最小弯曲半径 R(mm) 125
端部自由长度 X(mm) 60
防护等级 IP65
工作温度 (℃) ﹣5℃…+80℃
无有害物质 符合RoHS 标准
电缆材料 SRPVC/FRPVC
护套颜色 RAL7001
规范引用 UL758-2464
线的颜色 针脚
白 1
棕 2
緑 3
黄 4
灰 5
粉 6
蓝 7
红 8
黑 9
紫 10
灰-粉 11
红-蓝 12
绿-白 13
棕-绿 14
黄-白 15
棕-黄 16
灰-白 17
棕-灰 18
白-粉 19
棕-粉 20
蓝-白 21
棕-蓝 22
红-白 23
棕-红 24
黑白 25
1: 25针SUU-D母头
2：电缆
3：螺钉
4：外壳
5：电缆锁紧螺母
1）零件清单
• 松开螺母5
• 用螺丝刀从A、B两
处将母头1 推出
• 推电缆2直至母头1
离开外壳4
• 将电缆2和母头翻
转180°
• 将母头1和电缆2推
入外壳4
• 推母头进入A、B两
处卡槽内
• 拧紧螺母5
4）技术参数 5）针脚分配
● Loosen the nut 5
● Use A screwdriver to push out
the female head 1 from points A
and B
● Push Cable 2 until the female
connector 1 leaves the casing 4
●Flip Cable 2 and the female
connector 180°
●Push female head 1 and cable 2
into housing 4
●Push the female head into the
two slots A and B
● Tighten the nut 5
■ Technical parameters■ 44 pin connection cable
Model
Cable structure (mm ²)
Cable diameter D (mm)
Minimum bending radius R (mm)
Free length at the end X (mm)
Protection grade
Operating temperature: ℃
Free of harmful substances
Cable materia
Sheath color
Standard citation
Color of
the line
Color of
the line
1:44 needle SUU-D female head
2: Cable
3: Screw
4: Shell
5: Cable lock nut
3
71 Stitch
Select the appropriate control box from an economic perspective
Main technical parameters of the control box
Communication type IO-Link
Electrical connection M12 plug with 5 pins
Electrical connection Sub-D plug
Baud rate COM3 [kbps] 230.4
COM2 [kbps] 38.4
Inherent power consumption, logic power supply PS [mA] 30
Inherent power consumption, valve power supply PL [mA] 30
Maximum electromagnetic coil L1-S-8-PT 16
L1-S-16-PT 32
L1-S-24-PT 48
Maximum valve number L1-S-8-PT 8
L1-S-16-PT 16
L1-S-24-PT 24
Environment temperature [℃] -5~60
The protection grade complies with the EN60529 standard IP65
LED display
Color State Function
Status LED×1 Red
Green
Blue
The light doesn't work.
The green light is always on.
The green light is flashing.
The red light is flashing.
The red light is always on
The blue light is always on
Power supply PS(+24V)
Load power supply PL(+24V)
Power supply PS(OV)
Communication signal C/Q
Load power supply PL(OV)
Pin allocation IO-Link interface
Stitch IO-Link corresponding name
1
2
3
4
5
42.5
91.2
27
90.5
Wiring diagram
■ IO-Link Electrical control box
+24V control module power supp+24V load power supply
C/Q(Signal)
0V control module power supply
0V load power supply
VGVT Series
There is no 24V logic
The data communication is abnormal
Normal operation
Status equipment failure
The 24V load voltage supply is abnormal
All the way or more through or open road
Brown
White
Black
Blue
Grey
1 4.5 4.5
57.3
10.5
L3
10
12
两侧3-G1/8
72
41.9 18.9
ply
Support Agreement
PROFINET
ETHERNET/IP
ETHERCAT
CIEBS
Power connection M12 male head A port 4-core
Bus communication interface（OUT) M12 female head D port 4 cores Bus communication interface（IN)
Cable type Shielded twisted pair cable minimum STP CAT5/STP CAT5e, in compliance with IEEE 802.3
Data transmission rate 100 Mbps（ PROFINET/ETHERCAT）
10Mbps/100Mbps(Adaptive ETHERNET/IP)
Number of output coils Up to 48 routes
The valve island consumes power（ Ius） ≤0.1A （ 21.6...26.4VDC）
Solenoid valve total power consumption（ Iua） ≤4A （ 22.8...26.4VDC）
Working temperature -10～50 ℃
Waterproof grade IP54
Stitch Corresponding name
1 UA Actuator Power
2 GND Actuator Power
3 US Bus Power
4 GND Bus Power
1 Tx+ Send data +
2 Rx+ Receive data +
3 Tx- Send data -
4 Rx- Receive data -
1 Tx+ Send data +
2 Rx+ Receive data +
3 Tx- Send data -
4 Rx- Receive data -
■ ���F��W Multi-protocol electrical control box
■ Technical parameters
■ Pin allocation
73 LED Display Function
PF
Green light ETHERNET/IP protocol
Orange PROFINET protocol
Blue ETHERCAT protocol
White CIEBS protocol
X1
Constant green light
Green light flashing 1 HZ
Green red green flickering
Red flashing 1HZ
Constant red light
The LED indicator is off
Constant green light
Constant green light
Green light flashing 1 HZ
Green red green flickering
Red flashing 1HZ
Constant red light
The LED indicator is off
The LED indicator is off
Constant green light
The LED indicator is off
X2
Working status: Equipment operation
Normal standby: The device is not configured
Self-test: The device is being tested on
Recoverable fault
Unrecoverable fault
There is no input voltage for US
Connected
Not connected
Self-test: The device is being tested on
Connection timeout
IP duplication
US No input voltage or IP address
The device is connected to the Ethernet
The device (IN) sends/receives Ethernet frames
The device is not connected to the Ethernet
The device (OUT) is connected to the Ethernet
The device (OUT) sends/receives Ethernet frames
The device (OUT) is not connected to the Ethernet
The input voltage is normal
Low input voltage (< 18V
The output voltage is normal
Low output voltage (< 18V
There is no output voltage (< 11V).
Pin 1: Brown
Pin 2: White
Pin 3: Blue
Pin 4: Black
L/A1 Yellow light flashing
L/A2 Yellow light flashing
US Green
Red flashing
UA
Green
Red flashing
Constant red light
M12 plug 4 pin straight female head
5
4×0.34
50
250 V AC
250 V DC
IP68
-40~80
PUR drag chain cable
Black
Model Stitch Cable length
FCC-M415-0000-1A-006-PH0434-030 4 pins straight female head
4 pins straight female head
3 meter cable
FCC-M415-0000-1A-006-PH0434-050 5 meter cable
±0.13
图 法
＞5.0～18 ＞18～75
±0.07 ±0.20 ±0.27
≤5.0 ＞75
审核 重量
校对
序号 修订版次
设 计 变 更
名
称
比例
未注
公差
变更单编号
图
号
材
料 制图
设计 李 刚
石尧峰 2022.6.6
1
2
3
4 4
3 1
2 引脚1：黄
引脚2：白
引脚3：橙
引脚4：蓝
1
2
3
4 4
3
2
1
Ⅰ Ⅱ
屏蔽至扣边
Ⅱ
4
2
1
4
3
1
2
3
2
4
1
1.....8
引脚1：黄
引脚2：白
引脚3：橙
引脚4：蓝
屏蔽至扣边
Ⅰ
3
5
6
7
8
4
1
2
3
3
4
2
1
■ LED display
■ �-pin female connector - Electrical control box power cable (suitable for ���F�� control box)
+24V load power supply
0V load power supply
+24V control module power supply
0V control module power supply
8 7 A
B
C
D
E
VGVT Series
Electrical connection
Cable diameter (mm
Number of wires x cross-sectional area (mm2)
Minimum bending radius R(mm
Maximum supply voltage AC UB
Maximum supply voltage: DC UB
Protection grade
Operating temperature ° C
Cable material
Sheath color
74
6 5 4 3 2 1
工艺
审核
设计
标记 处数 分区 更改文件号 签名 年、月、日
批准
Administrator 2022/11/8 标准化 阶段标记 重量(Kg) 比例
Profint 总线网关
1 : 1
PROFINET
M12 male head A port 5-core
M12 female head D port 4 cores
Shielded twisted pair cable minimum STP CAT5/STP CAT5e, in compliance with IEEE 802.3
Data transmission rate 100 Mbps（ PROFINET/ETHERCAT）
10Mbps/100Mbps(Adaptive ETHERNET/IP)
Up to 48 routes
≤0.1A （ 21.6...26.4VDC）
≤4A （ 22.8...26.4VDC）
-10～50 ℃
IP54
Stitch Corresponding name
1 Working voltage
Electronic components/sensors（power system）UEL/SEN 24V
2 Load voltage
Valve/output terminal（power load） UVAL/OUT 24V
3 Working voltage UEL/SEN 0V
4 Load voltage UVAL/OUT 0V
5 Functional grounding（function earth） FE
1 Tx+ Send data +
2 Rx+ Receive data +
3 Tx- Send data -
4 Rx- Receive data -
1 Tx+ Send data +
2 Rx+ Receive data +
3 Tx- Send data -
4 Rx- Receive data -
■ VCEU-D��-PN protocol electrical control box (PROFINET protocol)
■ Technical parameters
■ Pin allocation
Support Agreement
Power connection
Bus Communication Interface (TP1)
Bus Communication Interface (TP2)
Cable type
Number of output coils
Valve Island Power consumption (lus)
Solenoid Valve Total Power Consumption (lua)
Working temperature
Waterproof grade
1
2
3
4 4
3 1
2 引脚1：黄
引脚2：白
引脚3：橙
引脚4：蓝
1
2
3
4
Ⅰ
屏蔽2
1
4
3
2
4
1
1.....8
引脚1：黄
引脚2：白
引脚3：橙
引脚4：蓝
屏蔽至扣边
Ⅰ
3
4
引脚1：棕
引脚2：白
引脚3：蓝
引脚4：黑
1
2
3
3
4
2
1
75 Pin 1: Brown
Pin 2: White
Pin 3: Blue
Pin 4: Black
Pin 5: Gray or Green/Yellow
+24V control module power supply
+24V load power supply
0V control module power supply
0V load power supply
PE grounding
LED display
LED Display Function
The green LED indicator light is on
Normal operating state
The working voltage is normal (within the allowable range)
The load voltage is normal (within the allowable range)
The green LED indicator light is flashing
(flashing frequency: 1 Hz)
The working voltage is lower than the required voltage
The load voltage is lower than the required voltage
The LED indicator light goes out The working voltage is abnormal
The operating voltage is below the minimum required for
the diagnostic function
The green LED indicator light is on Normal operating state
The green LED indicator light is flashing
(flashing frequency: 1 Hz)
Diagnostic status
The system power supply or auxiliary power supply
is under-voltage
The red LED indicator light comes on
After debugging, the wrong device was connected
(a device with inconsistent hardware configuration
in the control system or an incompatible product)
The LED indicator light goes out The product is not connected to the bus node
The red LED indicator light is flashing
(flashing frequency: 1 Hz)
Communication failure
Communication failure or interruption between the control
system and the bus node
The LED indicator light goes out Normal operating state
The green LED indicator light is on Normal operating state
The network connection is normal
To locate the connected products (\" module positioning \"), for example:
When configuring hardware in the control system or locating faults
Two green LED indicator lights, TP1 and TP2,
are flashing (flashing frequency: 1 Hz)
The LED indicator light goes out Not connected to the network
M12 plug 5-pin straight female connector
5
5×0.34
50
125 V AC
125 V DC
IP68
-40~80
PUR drag chain cable
Grey
Model
PS
Working voltage state
(Power System)
X1 or X2
The internal communication
state between the bus
nodes and the connected
products
NF
Network status/network
failure(Network Failure)
TP1/TP2
Network connection
status(Link1/Link2)
Stitch Cable length
FCC-M415-0000-1A-006-PH0534-030 5 pin straight female head 3 meter cable
FCC-M415-0000-1A-006-PH0534-050 5 pin straight female head 5 meter cable
±0.13
图 法
＞5.0～18 ＞18～75
±0.07 ±0.20 ±0.27
≤5.0 ＞75
审核
批准
重量
版次
校对
序号 修订版次
设 计 变 更
名
称
比例
未注
公差
变更单编号
A版0次
图
号
材
料 制图
设计 李 刚
石尧峰 2022.6.6
4
3
2
1
Ⅱ
扣边
Ⅱ
4
1
2
3
5
6
7
8
2
3
4
5
1
4
2
5 3
1
成型刀20*20
压铸铝
2:1
VF4140
● �-pin female connector - Electrical control box power cable (suitable for VCEU-D��-PN control box)
VGVT Series
Electrical connection
Cable diameter (mm)
Number of wires × Cross-sectional area (mm ²)
Minimum bending radius R (mm)
Maximum supply voltage AC UB
Maximum supply voltage: DC UB
Protection grade
Operating temperature: ℃
Cable material
Sheath color
76
Electrical connection M12 plug with 4 pins
5
4×22 AWG
50
125 V AC
125 V DC
IP68
-20~60
PUR drag chain cable
Green
Shield to the edge
Pin 1: Yellow
Pin 2: White
Pin 3: Orange
Pin 4: Blue
Pin 1: Yellow
Pin 2: White
Pin 3: Orange
Pin 4: Blue
Shield to the edge
5
4×0.34
50
125 V AC
125 V DC
IP68
-20~60
PUR drag chain cable
FCC-M414-E834-5D-033-PHGPNC-005 M12 straight male /RJ45 straight male 0.5 meter cable
FCC-M414-E834-5D-033-PHGPNC-015 M12 straight male /RJ45 straight male 1.5 meter cable
FCC-M414-E834-5D-033-PHGPNC-050 M12 straight male /RJ45 straight male 5 meter cable
FCC-M414-E834-5D-033-PHGPNC-100 M12 straight male /RJ45 straight male 10 meter cable
0.5 meter cable
1.5 meter cable
5 meter cable
10 meter cable
FCC-M414-M414-5D-033-PHGPNC-005 M12 straight male /M12 straight male
FCC-M414-M414-5D-033-PHGPNC-015 M12 straight male /M12 straight male
FCC-M414-M414-5D-033-PHGPNC-050 M12 straight male /M12 straight male
FCC-M414-M414-5D-033-PHGPNC-100 M12 straight male /M12 straight male
1
2
3
4 4
3 1
2 1
2
3
4 4
3
2
1
Ⅰ Ⅱ
Ⅱ
4
2
1
4
3
1
2
3
2
4
1
1.....8
引脚1：黄
引脚2：白
引脚3：橙
引脚4：蓝
屏蔽至扣边
Ⅰ
3
5
6
7
8
±0.13
图 法
＞5.0～18 ＞18～75
±0.07 ±0.20 ±0.27
≤5.0 ＞75
审核
批准
重量
版次
校对
序号 修订版次
设 计 变 更
名
称
比例
未注
公差
变更单编号
A版0次
图
号
材
料 制图
设计 李 刚
石尧峰 2022.6.6
1
2
3
4 4
3 1
2 引脚1：黄
引脚2：白
引脚3：橙
引脚4：蓝
1
2
3
4 4
3
2
1
Ⅰ Ⅱ
屏蔽至扣边
Ⅱ
4
2
1
4
3
1
2
3
2
4
1
1.....8
Ⅰ
3
5
6
7
8
4
引脚1：棕
引脚2：白
引脚3：蓝
引脚4：黑
1
2
3
3
4
2
1
2
3
4
5
1
引脚1：棕
引脚2：白
引脚3：蓝
引脚4：黑
引脚5：灰色或绿色/黄色 4
2
5 3
1
成型刀20*20
压铸铝
2:1
VF4140
■ �-pin female connector - Electrical control box power cable
Model Stitch Cable length
Model Stitch Cable length
Cable diameter (mm)
Number of wires × Cross-sectional area (mm ²)
Minimum bending radius R (mm)
Maximum supply voltage AC UB
Maximum supply voltage: DC UB
Protection grade
Operating temperature: ℃
Cable material
Sheath color
Electrical connection
Cable diameter (mm)
Number of wires × Cross-sectional area (mm ²)
Minimum bending radius R (mm)
Maximum supply voltage AC UB
Maximum supply voltage: DC UB
Protection grade
Operating temperature: ℃
Cable material
Sheath color
M12 plug with 4 pins
Green
77 Order data
Name Explanation Function
Muffler Used for thread M5
Used for thread G1/8
Used for thread G1/4
Used for thread G3/8
For threaded M5 cannula diameter 4mm
For threaded M5 cannula diameter 6mm
For thread M5
For thread G1/8
For thread G1/4
For thread G38
For bottom-connected and half-tube busbars 10
For bottom-connected and half-tube busbars 14
For bottom-connected and half-tube busbars 18
For bottom-connected busbar 14 (with screws and gaskets)
For semi-tube manifold 14 (with screws and gaskets)
For bottom-connected busbar 14 (with screws and gaskets)
For semi-tube manifold 14 (with screws and gaskets)
For threaded G1/8 cannula diameter 4mm
For threaded G1/8 cannula diameter 6mm
For thread G1/4 cannula diameter 6mm
For thread G1/4 cannula diameter 8mm
For thread G1/4 cannula diameter 10mm
For thread G3/8 cannula diameter 12mm
For threaded G1/8 cannula diameter 4mm
For threaded G1/8 cannula diameter 6mm
For threaded G1/8 cannula diameter 8mm
For threaded G1/4 cannula diameter 6mm
For threaded G1/4 cannula diameter 8mm
For threaded G1/4 cannula diameter 10mm
For threaded G1/4 cannula diameter 12mm
For threaded G3/8 cannula diameter 12mm
PSLU-M5
PSLU-01
PSLU-02
PSLU-03
Straight joint with O-ring
(Straight pipe thread)
PPS4-M5
PPS6-M5
PCA04-G01
PCA06-G01
PCA06-G02
PCA08-G02
PCA08-G02
PCA10-G03
Hexagon socket straight joint
(Tapered sealing thread)
PPS4-01
PPS6-01
PPS8-01
PPS6-02
PPS8-02
PPS10-02
PPS12-02
PPS12-03
Plug SP01-M5
SP01-01G
SP01-02G
SP01-03G
Blind plate
VGVU-M14-T
VGVU-S14-T
Air source plate
VGVU-M14-X
VGVU-S14-X
Isolation component VGVA-VABD-7-B
VGVA-VABD-10-B
VGVA-VABD-12-B
■ Other attachments VGVT Series
电 气 接 口
电气接口10.3
电 气 接 口
78
VUVG Series (Tubular and Plate type)
Series
5 ：DC24V
■ Product features
VUVG L 10 25B A 5 LZ
1. Standard type or energy-saving type are available as options. The energy-saving type has a power as
low as 0.4W.
2. Pilot-operated drive structure, 11 valve functions to choose from.
3. Manual operation mode, push-button type with locking.
4. The tubular solenoid valve can be directly installed or installed on the manifold, and can be equipped
with internal pilot or external pilot.
5. The bottom-mounted solenoid valve needs to be installed on the manifold and can be equipped with
either an internal pilot or an external pilot.
■ VUVG solenoid valve (tube type and plate type) order code
Valve structure
L: Tube valve
S: Tube valve, including gasket and
installation screw
B: Plate valve (for busbar installation)
Valve width
10:10mm
14:14mm
18:18mm
A: Standard type (1W)
B: Energy-saving type (0.4W after 20ms)
LZ: L-shaped socket type, with indication
Lamp and overvoltage protection circuit
Note: By default, it comes with a cable
plug, with a cable length of 0.3 meters
Blank: Internal pilot
Z: External leader
Note: If the valve structure is selected as B plate type
By default, the external pilot of the valve can only be
selected as L or S
There are distinctions between internal and external
pilot valves for tube valves
The function of the valve on the valve position:
23R: Two two-position three normally closed type (air reset)
23H: Two-position three-way open-close type (one normally open
and one normally closed and reset)
23U: Two two-position three-position normally open type (gas reset)
23VR: Two two-position three normally closed type (spring return)
23VH: Two-position three-way opening and closing type (one
normally open and one normally closed with spring return)
23VU: Two two-position three-position normally open type
(spring return)
25M: Two-position five-way single electronic control (pneumatic reset)
25B: Two-position five-way dual electronic control
35C: Three-position five-way middle seal type
35P: Three-position five-way medium voltage type
35E: Three-position five-channel medium leakage type
Φ 3.2
2-
10.3
33.4
3
2 -M 5
Φ 2.4
2-
24
12
27
3-M5
2
4 8
11.5
27
4.4
手动控制
电 气 接 口
18.3
68.3
80.8
18.3
48
2 Φ 2.4
2 -
2 -M 5
M 3
11.5
8
1 .53
24
12
3-M 5
2
82 .6
107.6
53.8
手动
Φ 3.2
2-
10.3
3
2 -M 5
Φ 2.4
2-
24
12
27
3-M5
2
4 8
11.5
27
4.4
手动控电 气 接 口
18.3
68.3
80.8
24
12
3-M 5
4.4 27
11 .5
2
48
18 .3
Φ 2.4
2 -
2 -M 5
Φ 3 .2
2-
82 .6
107.6
10.3
电气接口
53.8
手动控制
Φ 3.2
2-
10.3
33.4
3
2 -M 5
Φ 2.4
2-
2
4 8
11.5
27
4.4
手动控制
18.3
68.3
80.8
18.3
48
2 Φ 2.4
2 -
2 -M 5
M 3
11.5
8
1 .5
3
24
12
3-M 5
4.4 27
11 .5
2
48
18 .3
Φ 2.4
2 -
2 -M 5
Φ 3 .2
2-
33.4
82 .6
107.6
10.3
口
53.8
手动控制 手动控制
手动控制
电气接口
11 .5
2
1.5
8
18.3
48
Φ 2.4
2 -
2-M 5
手动控制 M
手动控制
3
24
12
3-M 5
4.4 27
11 .5
2
48
18 .3
Φ 2.4
2 -
2 -M 5
Φ 3 .2
2-
82 .6
107.6
10.3
电气接口
53.8
手动控制
Φ 3.2
2-
33.4
2 -M 5
Φ 2.4
2-
24
12
27
3-M5
27
4.4
68.3
80.8
2 Φ 2.4
2 -
2 -M 5
8
1 .5
M3外先导Φ 3.2
2-
10.3
33.4
3
2 -M 5
Φ 2.4
2-
24
12
27
3-M5
2
4 8
11.5
27
4.4
手动控制
电 气 接 口
18.3
68.3
80.8
18.3
48
2 Φ 2.4
2 -
2 -M 5
M311.5
8
3
24
12
3-M 5
4.4 27
2
Φ 2.4
2 -
2 -M 5
Φ 3 .2
2-
33.4
82 .6
107.6
10.3
电气接口
53.8
电气接口
2
Φ 2.4
2 -
2-M 5
79 VUVG Series (Tubular and Plate type)
M3外先导接口
18.3
48
2 Φ 2.4
2 -
2 -M 5
M 3
11.5
8
1 .5
3
33.4
手动控制
手动控制
电气接口
11 .5
2
1.5
8
18.3
48
Φ 2.4
2 -
2-M 5
手动控制 M
手动控制
3
M3外先导接口
M3外先导接口
333.4
手动控制
电气接口
11 .5
2
1.5
8
18.3
48
Φ 2.4
2 -
2-M 5
手动控制 M
手动控制
3
口
1 .5
手动控制
1.5
8
M3外先导接口
M3外先导接口
■ VUVG-L�� Tube valve
■ VUVG-S�� Tube Valve (with Screw and Gasket)
■ VUVG-B�� Plate Valve (default with screws and gasket)
80
M3外先导接口
M3外先导接口
■ Graphic symbol for tubular solenoid valve
Model Tubular internal pilot Model Tubular external pilot
VUVG-L10/S10-23R VUVG-L10/S10-23R-Z
VUVG-L14/S14-23R VUVG-L14/S14-23R-Z
VUVG-L18/S18-23R VUVG-L18/S18-23R-Z
VUVG-L10/S10-23U VUVG-L10/S10-23U-Z
VUVG-L14/S14-23U VUVG-L14/S14-23U-Z
VUVG-L18/S18-23U VUVG-L18/S18-23U-Z
VUVG-L10/S10-23H VUVG-L10/S10-23H-Z
VUVG-L14/S14-23H VUVG-L14/S14-23H-Z
VUVG-L18/S18-23H VUVG-L18/S18-23H-Z
VUVG-L10/S10-23VR VUVG-L10/S10-23VR-Z
VUVG-L14/S14-23VR VUVG-L14/S14-23VR-Z
VUVG-L18/S18-23VR VUVG-L18/S18-23VR-Z
VUVG-L10/S10-23VU VUVG-L10/S10-23VU-Z
VUVG-L14/S14-23VU VUVG-L14/S14-23VU-Z
VUVG-L18/S18-23VU VUVG-L18/S18-23VU-Z
VUVG-L10/S10-23VH VUVG-L10/S10-23VH-Z
VUVG-L14/S14-23VH VUVG-L14/S14-23VH-Z
VUVG-L18/S18-23VH VUVG-L18/S18-23VH-Z
VUVG-L10/S10-25M VUVG-L10/S10-25M-Z
VUVG-L14/S14-25M VUVG-L14/S14-25M-Z
VUVG-L18/S18-25M VUVG-L18/S18-25M-Z
VUVG-L10/S10-25B VUVG-L10/S10-25B-Z
VUVG-L14/S14-25B VUVG-L14/S14-25B-Z
VUVG-L18/S18-25B VUVG-L18/S18-25B-Z
VUVG-L10/S10-35C VUVG-L10/S10-35C-Z
VUVG-L14/S14-35C VUVG-L14/S14-35C-Z
VUVG-L18/S18-35C VUVG-L18/S18-35C-Z
VUVG-L10/S10-35P VUVG-L10/S10-35P-Z
VUVG-L14/S14-35P VUVG-L14/S14-35P-Z
VUVG-L18/S18-35P VUVG-L18/S18-35P-Z
VUVG-L10/S10-35E VUVG-L10/S10-35E-Z
VUVG-L14/S14-35E VUVG-L14/S14-35E-Z
VUVG-L18/S18-35E VUVG-L18/S18-35E-Z
81 VUVG Series (Tubular and Plate type)
L/min 1、3 、5 2、4
VUVG-L10/S10-23R
10mm
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Internal leader
180
M5
On the valve body On the valve body
On the valve body On the valve body
M5
VUVG-L10/S10-23U 180
VUVG-L10/S10-23H 180
VUVG-L10/S10-23VR 150
VUVG-L10/S10-23VU 150
VUVG-L10/S10-23VH 150
VUVG-L10/S10-25M 280
VUVG-L10/S10-25B Bistable state 280
VUVG-L10/S10-35C 180
VUVG-L10/S10-35P 180
VUVG-L10/S10-35E 180
VUVG-L10/S10-23R-Z
10mm External leader, M3
On the valve body
180
M5 M5
VUVG-L10/S10-23U-Z 180
VUVG-L10/S10-23H-Z 180
VUVG-L10/S10-23VR-Z 150
VUVG-L10/S10-23VU-Z 150
VUVG-L10/S10-23VH-Z 150
VUVG-L10/S10-25M-Z 280
VUVG-L10/S10-25B-Z Bistable state 280
VUVG-L10/S10-35C-Z 180
VUVG-L10/S10-35P-Z 180
VUVG-L10/S10-35E-Z 180
VUVG-L10/S10-23R
-5~60 -5~60 24±10% Optional: 1W
or 0.4W
Optional: 1W
or 0.4W
10 0.25~0.8 0.15~0.8
VUVG-L10/S10-23U 10 0.25~0.8 0.15~0.8
VUVG-L10/S10-23H 10 0.25~0.8 0.15~0.8
VUVG-L10/S10-23VR 10 0.3~0.8 -0.09~0.8
VUVG-L10/S10-23VU 10 0.3~0.8 -0.09~0.8
VUVG-L10/S10-23VH 10 0.3~0.8 -0.09~0.8
VUVG-L10/S10-25M 15 0.2~0.8 -0.09~0.8
VUVG-L10/S10-25B - 15 0.15~0.8 -0.09~0.8
VUVG-L10/S10-35C 10 0.2~0.8 -0.09~0.8
VUVG-L10/S10-35P 10 0.2~0.8 -0.09~0.8
VUVG-L10/S10-35E 10 0.2~0.8 -0.09~0.8
VUVG-L10/S10-23R-Z
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-L10/S10-23U-Z 10 0.25~0.8 0.15~0.8
VUVG-L10/S10-23H-Z 10 0.25~0.8 0.15~0.8
VUVG-L10/S10-23VR-Z 10 0.3~0.8 -0.09~0.8
VUVG-L10/S10-23VU-Z 10 0.3~0.8 -0.09~0.8
VUVG-L10/S10-23VH-Z 10 0.3~0.8 -0.09~0.8
VUVG-L10/S10-25M-Z 15 0.2~0.8 -0.09~0.8
VUVG-L10/S10-25B-Z - 15 0.15~0.8 -0.09~0.8
VUVG-L10/S10-35C-Z 10 0.2~0.8 -0.09~0.8
VUVG-L10/S10-35P-Z 10 0.2~0.8 -0.09~0.8
VUVG-L10/S10-35E-Z 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VUVG-L��/S�� Tubular Solenoid Valve —
—
—
—
Specification/Project Valve width Function Working medium Initial position Leading gas source Rated flow Air outlet Air outlet Steady state 3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Spring
Spring
Spring
Air reset
Air reset
Air reset
Air reset
Air reset
Compressed air
complies with
ISO8573
Compressed air
complies with
ISO8573
Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
Always open
Always open
Always open
Always open
Always closed
Medium pressure
Medium Leak
Middle seal
Medium pressure
Medium Leak
Middle seal
Always closed
Always closed
℃ ℃
Note: When the valve island of Specification 10 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.3Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa 99 14.7
82
Internal leader
On the valve body On the valve body
On the valve body On the valve body
External leader, M5
On the valve body
VUVG-L14/S14-23R
14mm
520
G1/8 G1/8
VUVG-L14/S14-23U 520
VUVG-L14/S14-23H 520
VUVG-L14/S14-23VR 500
VUVG-L14/S14-23VU 500
VUVG-L14/S14-23VH 500
VUVG-L14/S14-25M 530
VUVG-L14/S14-25B 530
VUVG-L14/S14-35C 500
VUVG-L14/S14-35P 530
VUVG-L14/S14-35E 500
VUVG-L14/S14-23R-Z
14mm
520
G1/8 G1/8
VUVG-L14/S14-23U-Z 520
VUVG-L14/S14-23H-Z 520
VUVG-L14/S14-23VR-Z 500
VUVG-L14/S14-23VU-Z 500
VUVG-L14/S14-23VH-Z 500
VUVG-L14/S14-25M-Z 530
VUVG-L14/S14-25B-Z 530
VUVG-L14/S14-35C-Z 500
VUVG-L14/S14-35P-Z 530
VUVG-L14/S14-35E-Z 500
Optional: 1W
or 0.4W
Optional: 1W
or 0.4W
VUVG-L14/S14-23R
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-L14/S14-23U 10 0.25~0.8 0.15~0.8
VUVG-L14/S14-23H 10 0.25~0.8 0.15~0.8
VUVG-L14/S14-23VR 10 0.3~0.8 -0.09~0.8
VUVG-L14/S14-23VU 10 0.3~0.8 -0.09~0.8
VUVG-L14/S14-23VH 10 0.3~0.8 -0.09~0.8
VUVG-L14/S14-25M 15 0.2~0.8 -0.09~0.8
VUVG-L14/S14-25B - 15 0.15~0.8 -0.09~0.8
VUVG-L14/S14-35C 10 0.2~0.8 -0.09~0.8
VUVG-L14/S14-35P 10 0.2~0.8 -0.09~0.8
VUVG-L14/S14-35E 10 0.2~0.8 -0.09~0.8
VUVG-L14/S14-23R-Z
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-L14/S14-23U-Z 10 0.25~0.8 0.15~0.8
VUVG-L14/S14-23H-Z 10 0.25~0.8 0.15~0.8
VUVG-L14/S14-23VR-Z 10 0.3~0.8 -0.09~0.8
VUVG-L14/S14-23VU-Z 10 0.3~0.8 -0.09~0.8
VUVG-L14/S14-23VH-Z 10 0.3~0.8 -0.09~0.8
VUVG-L14/S14-25M-Z 15 0.2~0.8 -0.09~0.8
VUVG-L14/S14-25B-Z - 15 0.15~0.8 -0.09~0.8
VUVG-L14/S14-35C-Z 10 0.2~0.8 -0.09~0.8
VUVG-L14/S14-35P-Z 10 0.2~0.8 -0.09~0.8
VUVG-L14/S14-35E-Z 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VUVG-L��/S�� Tubular Solenoid Valve
L/min 1、3 、5 2、4 Specification/Project Valve width Function Working medium Initial position Leading gas source Rated flow Air outlet Air outlet Steady state
-
-
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Spring
Spring
Spring
Air reset
Air reset
Air reset
Air reset
Air reset
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Bistable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
Compressed air
complies with
ISO8573
Compressed air
complies with
ISO8573
—
—
—
—
Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
Always open
Always open
Always open
Always open
Always closed
Medium pressure
Medium Leak
Middle seal
Medium pressure
Medium Leak
Middle seal
Always closed
Always closed
Note: When the valve island of Specification 14 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.3Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
℃ ℃ Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
102
127
℃ ℃ Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
L/min 1、3 、5 2、4 Specification/Project Valve width Function Working medium Initial position Leading gas source Rated flow Air outlet Air outlet Steady state
83 VUVG Series (Tubular and Plate type)
Internal leader
On the valve body On the valve body
On the valve body On the valve body
External leader, M5
On the valve body
Optional: 1W
or 0.4W
Optional: 1W
or 0.4W
VUVG-L18/S18-23R
18mm
1100
G1/4 G1/4
VUVG-L18/S18-23U 1100
VUVG-L18/S18-23H 1100
VUVG-L18/S18-23VR 1000
VUVG-L18/S18-23VU 1000
VUVG-L18/S18-23VH 1000
VUVG-L18/S18-25M 1200
VUVG-L18/S18-25B 1200
VUVG-L18/S18-35C 1000
VUVG-L18/S18-35P 1000
VUVG-L18/S18-35E 1000
VUVG-L18/S18-23R-Z
18mm
1100
G1/4 G1/4
VUVG-L18/S18-23U-Z 1100
VUVG-L18/S18-23H-Z 1100
VUVG-L18/S18-23VR-Z 1000
VUVG-L18/S18-23VU-Z 1000
VUVG-L18/S18-23VH-Z 1000
VUVG-L18/S18-25M-Z 1200
VUVG-L18/S18-25B-Z 1200
VUVG-L18/S18-35C-Z 1000
VUVG-L18/S18-35P-Z 1000
VUVG-L18/S18-35E-Z 1000
VUVG-L18/S18-23R
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-L18/S18-23U 10 0.25~0.8 0.15~0.8
VUVG-L18/S18-23H 10 0.25~0.8 0.15~0.8
VUVG-L18/S18-23VR 10 0.3~0.8 -0.09~0.8
VUVG-L18/S18-23VU 10 0.3~0.8 -0.09~0.8
VUVG-L18/S18-23VH 10 0.3~0.8 -0.09~0.8
VUVG-L18/S18-25M 15 0.2~0.8 -0.09~0.8
VUVG-L18/S18-25B 15 0.15~0.8 -0.09~0.8
VUVG-L18/S18-35C 10 0.2~0.8 -0.09~0.8
VUVG-L18/S18-35P 10 0.2~0.8 -0.09~0.8
VUVG-L18/S18-35E 10 0.2~0.8 -0.09~0.8
VUVG-L18/S18-23R-Z
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-L18/S18-23U-Z 10 0.25~0.8 0.15~0.8
VUVG-L18/S18-23H-Z 10 0.25~0.8 0.15~0.8
VUVG-L18/S18-23VR-Z 10 0.3~0.8 -0.09~0.8
VUVG-L18/S18-23VU-Z 10 0.3~0.8 -0.09~0.8
VUVG-L18/S18-23VH-Z 10 0.3~0.8 -0.09~0.8
VUVG-L18/S18-25M-Z 15 0.2~0.8 -0.09~0.8
VUVG-L18/S18-25B-Z 15 0.15~0.8 -0.09~0.8
VUVG-L18/S18-35C-Z 10 0.2~0.8 -0.09~0.8
VUVG-L18/S18-35P-Z 10 0.2~0.8 -0.09~0.8
VUVG-L18/S18-35E-Z 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VUVG-L��/S�� Tubular Solenoid Valve
-
-
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Spring
Spring
Spring
Air reset
Air reset
Air reset
Air reset
Air reset
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
Bistable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
Compressed air
complies with
ISO8573
Compressed air
complies with
ISO8573
—
—
—
—
Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
1 Always open
1 Always closed
Always open
Always open
Always open
Always open
Always closed
Medium pressure
Medium Leak
Middle seal
Medium pressure
Medium Leak
Middle seal
Always closed
Always closed
Note: When the valve island of Specification 18 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.3Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
84
Technical parameters of VUVG-L18/S18 Tubular Solenoid Valve
VUVG-L10/S10 2× two-position three-way, two-position five-way double electrically controlled,
three-position five-way pipe valve
Φ 3.2 2-
10.3
33.4
3
2 -M 5
Φ 2.4 2-
24
12
27
3-M5
2
4 8
11.5
27
4.4
手动控制
电 气 接 口
18.3
68.3
80.8
18.3
48
2 Φ 2.4 2 -
2 -M 5
M 3
11.5
8
1 .5
3
24
12
3-M 5
4.4 27
11 .5
2
48
18 .3
Φ 2.4 2 -
2 -M 5
Φ 3 .2 2-
33.4
82 .6
107.6
10.3
53.8
Manual control Manual control
手动控制
11 .5
2
1.5
8
18.3
48
Φ 2.4 2 -
2-M 5
Manual control M
Manual control
3
M3外先导接口 Φ 3.2 2-
10.3
33.4
3
2 -M 5
Φ 2.4 2-
24
12
27
3-M5
2
4 8
11.5
27
4.4
18.3
68.3
80.8
18.3
48
2 Φ 2.4 2 -
2 -M 5
M 3
11.5
8
1 .5
3
24
12
3-M 5
4.4 27
11 .5
2
48
18 .3
Φ 2.4 2 -
2 -M 5
Φ 3 .2 2-
33.4
82 .6
107.6
10.3
电气接口
53.8
手动控制 手动控制
Manual control
电气接口
11 .5
2
1.5
8
18.3
48
Φ 2.4 2 -
2-M 5
手动控制 M
手动控制 3
M3外先导接■ Overall dimensions
Electrical interface
Electrical interface
Electrical interface
Manual control
M3外先导接口
M3外先导接口
85 VUVG Series (Tubular and Plate type)
VUVG-L14/S14 two-position five-way single electrically controlled valve
VUVG-L14/S14 2× two-position three-way, two-position five-way double electrically controlled,
three-position five-way pipe valve
37
87
99.4
5.8
Φ3.2
2-
34.8
15
2-G1/8
66.5
25.8
2.7
14.7
电气接口
手动控制
30
15
36
3-G1/8
2-Φ2.8
15 手动控制
15
25.8
66.5
3.5
Φ3
2-
2-G1/8
M5
30
15
63.4
3-G1/8
102
37
127
Φ3.2
2-
5.8
14.7
15 25.8
30.2 66.5
Manual control Manual control
2-G1/8
Φ2.8
2-
34.8
Manual control Manual control 15 25.8
30.2 66.5
Φ2.8
2-
3.5
15
2-G1/8
M5
37
87
99.4
5.8
Φ3.2
2-
34.8
15
2-G1/8
66.5
25.8
2.7
14.7
Manual control
30
15
36
3-G1/8
2-Φ2.8
Manual control 15
15
25.8
66.5
3.5
Φ3
2-
2-G1/8
M5
30
15
63.4
3-G1/8
102
37
127
Φ3.2
2-
5.8
14.7
15 25.8
30.2 66.5
手动控制 手动控制
2-G1/8
Φ2.8
2-
34.8
电气接口
手动控制 手动控制 15 25.8
30.2 66.5
Φ2.8
2-
3.5
15
2-G1/8
M5电气接口
■ Overall dimensions
Electrical interface Electrical interface
Electrical interface
86
VUVG-L18/S18 two-position five-way single electrically controlled valve
VUVG-L18/S18 2× two-position three-way, two-position five-way double electrically controlled,
three-position five-way pipe valve
36
18
44
3-G1/4
52
6.5
Φ4.2 2-
103
115.5
18.7
Electrical interface
Φ3.2 2-
3 82
21 30.5
2-G1/4
Manual control 21
11.5
6
82
30.5
3
Φ3.2 2-
2-G1/4
M5
Manual control
36
18
71.5
3-G1/4
52
118
143
7
Φ4.2 2
18.7 -
21 30.5
30.5 82
Φ3.2 2-
2-G1/4
手动控制 手动控制 21 30.5
11.5
M5
30.5 82
Φ3.2 2-
2-G1/4
手动控制 手动控制
电气接口 电气接口
42.8
42.8
电气接
电气接口
36
18
44
3-G1/4
52
6.5
Φ4.2 2-
103
115.5
18.7
电气接口
Φ3.2 2-
3 82
21 30.5
2-G1/4
手动控制 21
11.5
6
82
30.5
3
Φ3.2 2-
2-G1/4
M5
手动控制
36
18
71.5
3-G1/4
52
118
143
7
Φ4.2 2
18.7 -
21 30.5
30.5 82
Φ3.2 2-
2-G1/4
Manual control Manual control 21 30.5
11.5
M5
30.5 82
Φ3.2 2-
2-G1/4
Manual control Manual control
42.8
42.8
电气接口
18.电气接口
■ Overall dimensions
Electrical interface Electrical interface
34.8
3 82
103
115.5
18.7
手动控制
2-M3
118
143
34.8
2-M3
30.5 82
7
电气接口
34.8
3 82
103
115.5
手动控制
2-M3
118
143
34.8
2-M3
30.5 82
电气接口
87 VUVG Series (Tubular and Plate type)
■ Graphic symbol for plate-type solenoid valve
Model Tubular internal pilot Model Tubular external pilot
VUVG-B10-23R VUVG-B10-25M
VUVG-B14-23R VUVG-B14-25M
VUVG-B18-23R VUVG-B18-25M
VUVG-B10-23U VUVG-B10-25B
VUVG-B14-23U VUVG-B14-25B
VUVG-B18-23U VUVG-B18-25B
VUVG-B10-23H VUVG-B10-35C
VUVG-B14-23H VUVG-B14-35C
VUVG-B18-23H VUVG-B18-35C
VUVG-B10-23VR VUVG-B10-35P
VUVG-B14-23VR VUVG-B14-35P
VUVG-B18-23VR VUVG-B18-35P
VUVG-B10-23VU VUVG-B10-3E
VUVG-B14-23VU VUVG-B14-35E
VUVG-B18-23VU VUVG-B18-35E
VUVG-B10-23VH
VUVG-B14-23VH
VUVG-B18-23VH
88
L/min 1、3 、5 2、4
VUVG-B10-23R
10mm
180
On the busbar
M5
VUVG-B10-23U 180
VUVG-B10-23H 180
VUVG-B10-23VR 150
VUVG-B10-23VU 150
VUVG-B10-23VH 150
VUVG-B10-25B - 280
VUVG-B10-35C 180
VUVG-B10-35P 180
VUVG-B10-35E 180
VUVG-B10-23R
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-B10-23U 10 0.25~0.8 0.15~0.8
VUVG-B10-23H 10 0.25~0.8 0.15~0.8
VUVG-B10-23VR 10 0.3~0.8 -0.09~0.8
VUVG-B10-23VU 10 0.3~0.8 -0.09~0.8
VUVG-B10-23VH 10 0.3~0.8 -0.09~0.8
VUVG-B10-25M Spring + gas 15 0.2~0.8 -0.09~0.8
VUVG-B10-25B - 15 0.15~0.8 -0.09~0.8
VUVG-B10-35C 10 0.2~0.8 -0.09~0.8
VUVG-B10-35P 10 0.2~0.8 -0.09~0.8
VUVG-B10-35E 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VUVG-B�� Plate Solenoid Valve
Note: When the valve island of Specification 10 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.4Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
℃ ℃ Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
Specification/Project Valve width Function Working medium Initial position Leading gas source Rated flow Air outlet Air outlet Steady state
Internal leader
On the valve body
Optional: 1W
or 0.4W
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/3 way
5/3 way
5/3 way
Always closed
1 Always open
1 Always closed
Always open
Always closed
1 Always open
1 Always closed
Always open
Medium pressure
Medium Leak
Middle seal
73L/min 1、3 、5 2、4 Specification/Project Valve width Function Working medium Initial position Leading gas source Rated flow Air outlet Air outlet Steady state
89 VUVG Series (Tubular and Plate type)
VUVG-B14-23R
14mm External leader, M5
On the busbar
520
G1/4
VUVG-B14-23U 520
VUVG-B14-23H 520
VUVG-B14-23VR 500
VUVG-B14-23VU 500
VUVG-B14-23VH 500
VUVG-B14-25M - 530
VUVG-B14-25B - 530
VUVG-B14-35C 500
VUVG-B14-35P 530
VUVG-B14-35E 500
VUVG-B14-23R
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-B14-23U 10 0.25~0.8 0.15~0.8
VUVG-B14-23H 10 0.25~0.8 0.15~0.8
VUVG-B14-23VR 10 0.3~0.8 -0.09~0.8
VUVG-B14-23VU 10 0.3~0.8 -0.09~0.8
VUVG-B14-23VH 10 0.3~0.8 -0.09~0.8
VUVG-B14-25M 15 0.2~0.8 -0.09~0.8
VUVG-B14-25B 15 0.15~0.8 -0.09~0.8
VUVG-B14-35C 10 0.2~0.8 -0.09~0.8
VUVG-B14-35P 10 0.2~0.8 -0.09~0.8
VUVG-B14-35E 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VUVG-B�� Plate Solenoid Valve Note: When the valve island of Specification 14 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.3Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
℃ ℃ Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
On the busbar On the valve body Optional: 1W
or 0.4W
Air reset
-
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
Compressed air
complies with
ISO8573
Always closed
1 Always open
1 Always closed
Always open
Always closed
1 Always open
1 Always closed
Always open
Medium pressure
Medium Leak
Middle seal
±0.13
图 法
＞5.0～18 ＞18～75
±0.07 ±0.20 ±0.27
≤5.0 ＞75
审核
批准
重量
版次
校对
序号 修订版次
设 计 变 更
名
称
比例
未注
公差
变更单编号
A版0次
图
号
材
料 制图
设计 李 刚
石尧峰 2022.6.6
成型刀20*20
压铸铝
2:1
VF4140
17
5 5
L
20 26.5
Φ4.5
4- 10.6
20
36.5
20 20
16
73
3-G1/4两端
L/min 1、3 、5 2、4 Specification/Project Valve width Function Working medium Initial position Leading gas source Rated flow Air outlet Air outlet Steady state
℃ ℃ Specification/Project Reset method Ambient temperature Medium temperature Working voltage
V DC
Power consumption
W
Fastest action frequency
Times/s
Internal leading time
Working pressure Mpa
External leading time
Working pressure Mpa
90
VUVG-B18-23R
18mm
1100
G3/8
VUVG-B18-23U 1100
VUVG-B18-23H 1100
VUVG-B18-23VR 1000
VUVG-B18-23VU 1000
VUVG-B18-23VH 1000
VUVG-B18-25M 1200
VUVG-B18-25B 1200
VUVG-B18-35C 1000
VUVG-B18-35P 1000
VUVG-B18-35E 1000
VUVG-B18-23R
-5~60 -5~60 24±10%
10 0.25~0.8 0.15~0.8
VUVG-B18-23U 10 0.25~0.8 0.15~0.8
VUVG-B18-23H 10 0.25~0.8 0.15~0.8
VUVG-B18-23VR 10 0.3~0.8 -0.09~0.8
VUVG-B18-23VU 10 0.3~0.8 -0.09~0.8
VUVG-B18-23VH 10 0.3~0.8 -0.09~0.8
VUVG-B18-25M 15 0.2~0.8 -0.09~0.8
VUVG-B18-25B 15 0.15~0.8 -0.09~0.8
VUVG-B18-35C 10 0.2~0.8 -0.09~0.8
VUVG-B18-35P 10 0.2~0.8 -0.09~0.8
VUVG-B18-35E 10 0.2~0.8 -0.09~0.8
■ Technical parameters of VUVG-B�� Plate Solenoid Valve
Note: When the valve island of Specification 18 is used with an external pilot, the following conditions must be met; otherwise, it cannot be driven. When the main valve is under negative
pressure, the pressure of the external pilot should be ≥ 0.3Mpa. When the main valve is under positive pressure, the external pilot pressure is greater than or equal to the main valve pressure.
On the busbar On the valve body
Optional: 1W
or 0.4W
Air reset
-
Air reset
Air reset
Air reset
Spring reset
Spring reset
Spring reset
Spring
Spring
Spring
External leader, M5
On the busbar
-
-
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Monostable state
Bistable state
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
3/2 way
5/2 way
5/2 way
5/3 way
5/3 way
5/3 way
Compressed air
complies with
ISO8573
Always closed
1 Always open
1 Always closed
Always open
Always closed
1 Always open
1 Always closed
Always open
Medium pressure
Medium Leak
Middle seal
10.3
电气接口
91 VUVG Series (Tubular and Plate type)
VUVG-B10 two-position five-way single electrically controlled plate valve
■ Overall dimensions
VUVG-B10 two-position five-way double electrically controlled plate valve
33.4
68.3
80.8
3 48
10.3
电气接口
手动控制
107.6
10.3 82.6
33.4
Electrical interface Electrical interface
Manual control Manual control
29.8 48
2-M2
2-M2
16 18.5
5 15
53
33.4
68.3
80.8
3 48
10.3
Electrical interface
Manual control
107.6
10.3 82.6
33.
电气接口 4
电气接口
手动控制 手动控制
29.8 48
2-M2
2-M2
16 18.5
5 15
53
87
99
2.7 66.5
2-M2.5
14.7
手动控制 电气接口
M
11 .5
2
48
18 .3
Φ 2.4
-
2 -M 5
手动控制 手动控制 11 .5
2
818.3
48
Φ 2.4
-
2-M 5
手动控制
24
12
3-M 5
4.4 27
11 .5
2
48
18 .3
Φ 2.4
2 -
2 -M 5
Φ 3 .2
2-
33.4
82 .6
107.6
53.8
手动控制 手动控制
电气接口
11 .5
2
1.5
8
18.3
48
Φ 2.4
2 -
2-M 5
手动控制 M
手动控制
3
92
■ Technical parameters of VUVG-B�� Plate Solenoid Valve
5
10.5
L
9.8
16.8
26.5
16.5 16.5
Φ4.5
4-
3-G1/8两端
5
10.5
L
9.8
16.8
26.5
16.5 16.5
Φ4.5
4-
3-G1/8两端
VUVG-B14 two-position five-way single electrically controlled plate valve
VUVG-B14 two-position five-way double electrically controlled plate valve
87
99
34.8
2.7 66.5
2-M2.5
14.7
14.7
电气接口
Manual control
Electrical interface
17
5 5
L
20 26.5
Φ4.5
4- 10.6
20
36.5
20 20
16
73
3-G1/4两端
34.8
14.7
102
127
34.
Electrical interface 8
Electrical interface
30.2 66.5
Manual control Manual control
2-M2.5
Manual control
36
18
44
3-G1/4
52
6.5
Φ4.2
2-
103
115.5
18.7
电气接口
Φ3.2
2-
3 82
21 30.5
2-G1/4
手动控制 21
11.5
6
82
30.5
3
Φ3.2
2-
2-G1/4
M5
手动控制
36
18
71.5
3-G1/4
52
118
143
7
Φ4.2
2
18.7 -
21 30.5
30.5 82
Φ3.2
2-
2-G1/4
手动控制 手动控制 21 30.5
11.5
M5
30.5 82
Φ3.2
2-
2-G1/4
手动控制
电气接口 电气接口
42.8
42.8
36
18
44
3-G1/4
52
6.5
Φ4.2
2-
103
115.5
18.7
电气接口
Φ3.2
2-
3 82
21 30.5
2-G1/4
手动控制 21
11.5
682
30.5
3
Φ3.2
2-
2-G1/4
M5
手动控制36
18
71.5
3-G1/4
52
118
143
7
Φ4.2
2
18.7 -
Φ3.2
2-
2-G1/4
11.5
M5 Φ3.2
2-
2-G1/4
电气接口 电气接口
42.8
42.8
1.5
M
手动控制
3
M3外先导接口
102
127
34.8
电气接口
30.2 66.5
控制 手动控制
2-M2.5
93 VUVG Series (Tubular and Plate type)
VUVG-B18 two-position five-way single electrically controlled plate valve
■ Overall dimensions
VUVG-B18 two-position five-way double electrically controlled plate valve
手动控制
34.8
3 82
103
115.5
18.7
Electrical interface
Manual control
2-M3
118
143
34.8
2-M3
30.5 82
18.7
电气接口 电气接口
34.8
3 82
103
115.5
18.7
电气接口
手动控制
2-M3
118
143
34.8
2-M3
30.5 82
18.7
Electrical interface Electrical interface
63 48
10.3
电气接口
94
Valve bit number 2 3 4 5 6 7 8 9 10 12 14 16
L 40.5 51 61.5 72 82.5 93 103.5 114 124.5 145.5 166.5 187.5
33.4
68.3
80.8
手动控制
107.6
2-M2
16 18.5
5 5
15
10.5
L
9.8
16.8
26.5
16.5 16.5
53
Φ4.5
4-
Both ends of 3-G1/8
■ Order code for VGVB tubular valve manifold
■ Dimension drawing of VGVB-L�� busbar
VGVB L14 4 Q10 U Q6S
Series: Tubular Valve group
Valve width
L10: Valve width 10mm
L14: Valve width 14mm
L18: Valve width 18mm
Blank: Insert directly
A: L-shaped elbow
Blank: Installed on both sides
L: Install on the left side
R: Install on the right side
Blank: No muffler
U: Resin muffler
N: Metal muffler
Blank: Installed on both sides
L: Install on the left side
R: Install on the right side
Valve port (in valve position)
Blank: No connector installed
Q4S: Quick connector 4mm
Q6S: Quick connector 6mm
Q8S: Quick connector 8mm
Note
Q4, Q6 suitable for valve width 10mm
Q6, Q8 suitable for valve width 14mm
Q6, Q8, Q10 are suitable for valve
width 18mm
The quantity of each function valve
2:2
3:3
...
16:16
The function of the valve on the valve
position:
R: Two, two, two, three, normally closed
type (air reset)
H: Two-position three-way open-close
type (one normally open and one
normally closed and reset)
U: Two two-position three-position
normally open type (gas reset)
VR: Two two-position three normally
closed type (spring return)
VH: Two-position three-way opening and
closing type (one normally open and one
normally closed with spring return)
VU: Two two-position three-position
normally open type (spring return)
M: Two-position five-way single
electronic control (pneumatic reset)
B: Two-position five-way dual electronic
control
C: Three-position five-way middle seal
type
P: Three-position five-way medium
pressure type
E: Three-position five-channel medium
leakage type
T: Empty blind plate
X: Air source plate
D: Internal isolation component
Valve bit number
2:2 valve positions
3:3 valve positions
4:4 valve positions
5:5 valve positions
6:6 valve positions
7:7 valve positions
8:8 valve positions
9:9 valve positions
10:10 valve positions
12:12 valve positions
14:14 valve positions
16:16 valve positions
Gas source interface
Blank: No connector installed
Q6: Quick connector 6mm
Q8: Quick connector 8mm
Q10: Quick connector 10mm
Q12: Quick connector 12mm
Q16: Quick connector 16mm
Note
Q6, Q8 suitable for valve width 10mm
Q10, Q12 suitable for valve width 14mm
Q12, Q16 suitable for valve width 18mm
95 VUVG Series (Tubular and Plate type)
Valve bit number 2 3 4 5 6 7 8 9 10 12 14 16
L 50 66 72 88 104 120 136 152 168 184 200 216
2 3 4 5 6 7 8 9 10 12 14 16
L 61 80 99 118 137 156 175 194 213 251 289 327
2.7 66.5 手动控制 17
5 5
L
20 26.5
Φ4.5
4- 10.6
20
36.5
20 20
16
73
At both ends of 3-G1/4
26 3
3 3
5 5
1 1
2
90
45
26 26
17.5
28.5
3-G3/ 8
Φ4.5
4-
6
21
L
19
6 10
VUVG-S10-T管VVU40.9
33
3-G1/4
安装螺钉
33
40.9
安2-M2
6 10
48
53
4
VUVG-S10-T管式阀盲板组件
11.5
25
48
12.5
33
40.9
89.8 安装螺钉
2-M2
6 10
48
53
6.5 14.4
66.5
73
2-M2.5 5
4
VUVG-S10-T管式阀盲板组件
VUVG-S14-T管式阀盲板组件 89.8 10.3 Valve bit number
■ VGVB-L�� tube valve bus size diagram
■ VGVB-L�� tube valve bus size diagram
96
30.2 66.5
2-M2
10
48
53
6 14.4
66.5
73
2-M2.5
5
4
VUVG-S10-T管式阀盲板组件
VUVG-S14-T管式阀盲板组件
VUVG-M10/S10-X气源板
VUVG-M18/S18-X气源板
21.5 19.5
43
82
3
122.6 18.7
40.9
33
3-G1/4
安装螺钉
3
11.5
25
48
12.5
3-M7
33
40.9
89.8 10.3
40.92-M2
6 10
48
53
6.5 14.4
66.5
73
2-M2.5
54
VUVG-S10-T管式阀盲板组件 VUVG-S14-T管式阀盲板组件
VUVG-M10/S10-X气源板
VUVG-M18/S18-X气源板
21.5 19.5
43
82
3
122.6 18.7
40.9
33
3-G1/4
3
11.5
25
48
12.5
3-M7
33
40.9
89.8 10.3
安装螺钉
2-M2
48
53
6.5 14.4
66.5
73
8
2-M3 2-M2.5 5.5
82
90
18.5
5
4
管式阀盲板组件
VUVG-S14-T管式阀盲板组件 VUVG-S18-T管式阀盲板组件
VUVG-M14/S14-X气源板 VUVG-M10/S10-X气源板
UVG-M18/S18-X气源板
21.5 19.5
43
82
3
122.6 18.7
3-G1/4
3
11.5
25
48
12.5
3-M7
89.8 10.3 107.7
33
40.9
14.7
16.5 16.8 2.7
33
66.5
安装螺钉
3-G1/8
2-M2
6 10
48
53
6.5 14.4
66.5
73
8
2-M2.5
18.5
5
4
VUVG-S10-T管式阀盲板组件
VUVG-S14-T管式阀盲板组件
VUVG- VUVG-M10/S10-X气源板
122.6 18.7
40.9
33
3
11.5
25
48
12.5
3-M7
33
40.9
89.8 10.3
33
40.9
安装螺钉 安装螺钉
3-G6.5 14.4
66.5
73
8
2-M3 2-M2.5 5.5
82
90
18.5
5
VUVG-S14-T管式阀盲板组件 VUVG-S18-T管式阀盲板组件
3
3-M7
10.3 107.7
33
40.9
14.7
16.5 16.8 2.7
33
66.5
安装螺钉 3-G1/8
8
2-M35.5
82
90
18.5
VUVG-S18-T管式阀盲板组件
107.7 14.7
■ VUVG-S��-T tube valve blind plate assembly size drawing ■ VUVG-M��/S��-X air source board assembly size drawing
■ VUVG-S��-T tube valve blind plate assembly size drawing ■ VUVG-M��/S��-X air source board assembly size drawing
■ VUVG-S��-T tube valve blind plate assembly size drawing ■ VUVG-M��/S��-X air source board assembly size drawing
Installation screw
Installation screw
Installation screw
14.8
16
9
29.5
8
2-M3
5.5
82
90
18.5
VUVG-S18-T管式阀盲板组件
VUVG-M14/S14-X气源板
107.7
33
14.7
16.5 16.8 2.7
33
66.5
安装螺钉
3-G1/8
8
2-M3
5.5
82
90
18.5
VUVG-S18-T管式阀盲板组件
VUVG-M14/S14-X气源板
107.7
33
40.9
14.7
16.5 16.8 2.7
33
66.5
安装螺钉
3-G1/8
2-M3
5.5
82
90
VUVG-S18-T管式阀盲板组件
14/S14-X气源板
107.7 14.7
16.5 16.8 2.7
33
66.5
97 VUVG Series (Tubular and Plate type)
G2-M5两端
3-G1/ 4两端
4.5
72.9
14.8
16
9
16.5
35.5
55.5
29.5
4.8
10
5
13.4
13.7 16
7
22
26 20
8.3 20.3
L
16
For example, when ordering the plate manifold assembly separately, if the valve width is confirmed to be 14mm, the external pilot air source is set to 5 digits, and no joints or mufflers are installed,
the code should be written as: VGVC-M14-5-Z
Φ4.5 4-
G1/ 8
2-M5两端
4两端
4.5
16
19.5
23.8
24
48.5
74
19
6
136
2-M5两端
3-G3/ 8两端
9.5
12.5
16.6
9.7
25.8
42
72.9
5
7.3
5
11.7
Both ends of 2-M5
Both ends of 3-G1/8
17.8 16
6 4
16
10.5
L
11.3
10.5
6.2
19
5
M5
Φ4.3 4-
55
59
6.4
38.5
24.5
5.5
55.5
4.8
10
5
13.4
13.7 16
7
22
26 20
8.3 6
20.3
L
16
2 3 4 5 6 7 8 9 10 12 14 16
L 40.5 51 61.5 72 82.5 93 103.5 114 124.5 145.5 166.5 187.5
■ Order code for VGVC plate valve manifold assembly
■ Size drawing of the manifold for VGVC-M�� plate valve
VGVC M14 4 Q10 U Q6S
Valve bit number
Series: Tubular Valve group
Valve width
M10: Valve width 10mm
M14: Valve width 14mm
M18: Valve width 18mm
Gas source interface
Blank: No connector installed
Q6: Quick connector 6mm
Q8: Quick connector 8mm
Q10: Quick connector 10mm
Q12: Quick connector 12mm
Q16: Quick connector 16mm
Note
Q6, Q8 suitable for valve width 10mm
Q10, Q12 suitable for valve width 14mm
Q12, Q16 suitable for valve width 18mm
Valve bit number
2:2 valve positions
3:3 valve positions
4:4 valve positions
5:5 valve positions
6:6 valve positions
7:7 valve positions
8:8 valve positions
9:9 valve positions
10:10 valve positions
12:12 valve positions
14:14 valve positions
16:16 valve positions
Blank: Insert directly
A: L-shaped elbow
Blank: Installed on both sides
L: Install on the left side
R: Install on the right side
Blank: No muffler
U: Resin muffler
N: Metal muffler
Blank: Installed on both sides
L: Install on the left side
R: Install on the right side
Valve port (in valve position)
Blank: No connector installed
Q4S: Quick connector 4mm
Q6S: Quick connector 6mm
Q8S: Quick connector 8mm
Note
Q4, Q6 suitable for valve width 10mm
Q6, Q8 suitable for valve width 14mm
Q6, Q8, Q10 are suitable for
valve width 18mm
Number of valves per function
2:2
3:3
...
16:16
The function of the valve on the valve
position:
R: Two, two, two, three, normally
closed type (air reset)
H: Two-position three-way open-close
type (one normally open and one
normally closed and reset)
U: Two two-position three-position
normally open type (gas reset)
VR: Two two-position three normally
closed type (spring return)
VH: Two-position three-way opening
and closing type (one normally open
and one normally closed with spring
return)
VU: Two two-position three-position
normally open type (spring return)
M: Two-position five-way single
electronic control (pneumatic reset)
B: Two-position five-way dual
electronic control
C: Three-position five-way middle seal
type
P: Three-position five-way medium
pressure type
E: Three-position five-channel medium
leakage type
T: Empty blind plate
X: Air source plate
D: Internal isolation component
