该页无缩略图
可充电锂离子电池组全系列运输合规
● 空运
● 海运
● 文件齐全
●通关高效
●全球业务无缝衔接
MSDS 报告
MSDS Report
| 申请商：Prepared For: | 深圳市博贝斯科技有限公司Shenzhen Bobes Technology Co., Ltd | ||
| 地址：Address: | 深圳市龙华区大浪街道华盛路134号雍景轩商业大厦1448室Room 1448, Yongjingxuan Commercial Building, 134 Huasheng Road,DalangStreet, Longhua District, Shenzhen, China | ||
| 产品名称：Product Name: | 可充电锂离子电池组Rechargeable lithium-ion battery Pack | ||
| 型号：Model: | BBS 2410-1 | ||
| 参数：Parameters: | 24V, 10Ah, 240Wh | ||
| 质量：Weight: | Approx(约). 1.6kg | ||
| 尺寸：Dimension: | 155.0mm×134.0mm×42.0mm(T×W×L) | ||
| 编制单位：Prepared By: | 深圳诚测检测技术有限公司Shenzhen CCJC Technology Co.,Ltd.广东省深圳市宝安区松岗街道溪头社区溪头路25号厂房101（1-3层）1-3/F., Factory Building 101, No.25, Xitou Road, Xitou, Songgang Subdistrict,Bao'an District, Shenzhen, Guangdong, China | ||
| 报告编号：Report No.: | CCJC2023A780605 | 接收日期：Accepted date: | 2025-12-16 |
| 检验日期：Inspection Date: | 2025-12-20 | 生效日期：Effective Date | 2026-01-01 |
| 李远勇 Li Yuan Yong 段 Roc cheng主检人：批准人：Tested by: 李远勇 Li Yuan Yong Approved by: 程鹏 Roc Cheng职位 Position: 测试工程师 Test Engineer 职位 Position: 技术负责人 Technical Manager钟庭芝Tosha 2hong审核人： 签发日期：Inspected by: 2025-12-20钟庭芝 Tosha Zhong Date of Issue:职位 Position: 项目工程师 Project Engineer | |||
Material Safety Data Sheet
第一部分 化学品及企业标识
Section 1 - Chemical Product and Company Identification
第二部分 危险性概述
第二部分 危险性概述
| 产品名称：Product Name: | 可充电锂离子电池组Rechargeable lithium-ion battery Pack |
| 产品型号Product Model: | BBS 2410-1 |
| 制造商：Manufacturer: | 东莞市博贝斯新能源科技有限公司Dongguan Bobes New Energy Technology Co., Ltd. |
| 地址：Address: | 广东省东莞市横沥镇新四黄塘路89号3号楼301室3nd Floor, Building D, Guangdong Huayuzhi Industrial Park, 89 Huangtang Road,Hengli Town, Dongguan City, China |
| 电话：Tel: | +86-769-88086182 |
| 传真：Fax: | / |
| 应急电话：Emergency Tel: | |
| 邮箱：E-mail: | 583703908@qq.com |
Section 2 - Hazards Identification
| 危险性类别Classification ofDanger | 见第十四部分。See section 14. |
| 浸入途径Primary Route(s)of Exposure | 眼睛，皮肤接触，摄入。Eye, skin contact, ingestion. |
| 健康危害Health Hazard | 正常条件下根据制造商的说明使用电池不会产生危害。使用不当的情况下，有破裂、起火、发烫、内部成分泄漏的危险，并可能造成意外损失。使用不当的行为包括但不限于下列情况：长时间充电、短路、投入火中、硬物撞击、尖物刺破、破碎，和破裂。The batteries are not hazardous when used according to the instructions ofmanufacturer under normal conditions. In case of abuse, there's risk of rupture,fire, heat, leakage of internal components, with could cause casualty loss.Abuses include but not limited to the following cases: charged for long time,short circuited, put into fire, whacked with hard object, punctured with acuteobject, crushed, and broken. |
| 化学名称Chemical Composition | CAS 编号CAS No. | 浓度或浓度范围(%)Concentration orconcentration ranges (%) |
| 镍酸锂Lithium nickel oxide | 12031-65-1 | 16.0 |
| 钴酸锂Lithium cobaltate | 12190-79-3 | 6.4 |
| 锰酸锂Lithium Manganate | 12057-17-9 | 9.6 |
| 石墨Graphite | 7782-42-5 | 17.0 |
| 六氟磷酸锂Lithium Hexafluorophosphate | 21324-40-3 | 2.0 |
| 碳酸乙烯酯Ethylene Carbonate(EC) | 96-49-1 | 4.0 |
| 碳酸甲乙酯Ethyl Methyl Carbonate | 623-53-0 | 7.0 |
| 碳酸丙烯酯Propylene Carbonate(PC) | 108-32-7 | 1.0 |
| 镍Nickel | 7440-02-0 | 2.0 |
| 铝Aluminium | 7429-90-5 | 12.0 |
| 铜Copper | 7440-50-8 | 8.0 |
| 碳Carbon | 7440-44-0 | 2.0 |
| 聚偏氟乙烯PolyvinylideneFluoride(PVD | 24937-79-9 | 4.0 |
| 聚乙烯Polyethlyene(PE) | 9002-88-4 | 3.0 |
| 聚对苯二甲酸乙二醇酯树脂poly(ethylene terephthalate) | 25038-59-9 | 6.0 |
标签根据EC指令。
Labeling according to EC directives.
不需要象形符号和危险短语。
No symbol and risk phrase are required.
注意: CAS 号是化学文摘服务注册号码。
Note: CAS number is Chemical Abstract Service Registry Number.
N/A =不适用。
N/A=Not apply.
第四部分 急救措施
第五部分 消防措施
第五部分 消防措施
| 眼睛Eye | 万一接触，立即用大量的清水冲洗至少15分钟，翻起上下眼睑，直到化学的残留物消失为止，迅速就医。Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper andlower eyelids. Get medical aid. |
| 皮肤Skin | 万一接触，用大量水冲洗至少15分钟，同时除去污染的衣物和鞋子，迅速就医。Remove contaminated clothes and rinse skin with plenty of water or shower for 15minutes. Get medical aid. |
| 吸入Inhalation | 立即从暴露处移至空气清新处，如果呼吸困难给予输氧，立即就医。Remove from exposure and move to fresh air immediately. Use oxygen if available. |
| 食入Ingestion | 饮用至少两杯牛奶或水。如果当事人仍然清醒可以采取催吐的方法，并且立即就医。Give at least 2 glasses of milk or water. Induce vomiting unless patient is unconscious.Call a physician. |
Section 5 - Fire Fighting Measures
第六部分 泄露应急处理
第六部分 泄露应急处理
| 危险特性Characteristics of Hazard | 高密度粉尘遇空气会形成爆炸性混合物。燃烧生成有毒烟雾。Dusts at sufficient concentrations can form explosive mixtures with air.Combustion generates toxic fumes. |
| 燃烧产生的危险物品Hazardous CombustionProducts | 二氧化碳。Carbon dioxide. |
| 灭火方法及灭火剂Fire-extinguishing Methodsand Extinguishing Media | 对于小型火险，可使用水枪，干冰（也就是液态二氧化碳）或化学泡沫。For small fires, use water spray, dry chemical, carbon dioxide orchemical foam. |
| 灭火注意事项Attention in Fire-extinguishing | 因为压强关系，要穿戴可呼吸式全身防护装备，MSHA/NIOSH（经认证或等效的），以及佩戴全套防护装置。Wear self-contained breathing apparatus in pressure-demand,MSHA/NIOSH (approved or equivalent) and full protective gear. |
Section 6 - Accidental Release Measures
| 个人预防措施、防护装备和 应急程序 Personal Precautions, protective equipment, and emergency procedures | 万一破裂。注意！腐蚀性物质。避免接触皮肤，眼睛或衣服。确保空气流 通。根据需要使用个人防护装备。将人员撤离到安全区域。让人们远离溢出/ 泄漏处和处于逆风。参考第七部分和第八部分中列出的防护措施。 In case of rupture. Attention! Corrosive material. Avoid contact with skin, eyes and clothing. Ensure adequate ventilation. Use personal protective equipment as required. Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak. Refer to protective measures listed in Sections 7 and 8. |
| 环境保护措施 Environmental Precautions | 防止产品污染土壤和进入下水道或水道。 Prevent product from contaminating soil and from entering sewers or waterways. |
| 方法和材料控制 Methods and materials for Containment | 出于安全，阻止泄漏，可以用干砂或泥土来遏制液体溢出，立即清理溢出 物。 Stop the leak if safe to do so. Contain the spilled liquid with dry sand or earth. Clean up spills immediately. |
| 清理的方法和材料 Methods and materials for cleaning up | 用惰性吸收剂(干砂或泥土)吸收溢出的材料。污染物转移到可接受的废物容 器中。收集所有受污染的吸收剂，按照第十三部分的说明进行处理。用洗涤 剂和水清洁污染区域，收集所有受污染的洗涤水，妥善处理。 Absorb spilled material with an inert absorbent (dry sand or earth). Scoop contaminated absorbent into an acceptable waste container. Collect all contaminated absorbent and dispose of according to directions in Section 13. Scrub the area with detergent and water; collect all contaminated wash water for proper disposal. |
第七部分 操作处置与储存
Section 7 - Handling and Storage
第八部分 接触控制和个体防护
第八部分 接触控制和个体防护
| 操作Handling | 拆解、挤压、直接放入火中或高温条件下，电池可能发生爆炸和燃烧。禁止短路或将电池正负极错误的安装在设备中。In case of rupture. Handle in accordance with good industrial hygiene andsafety practice. Avoid contact with skin, eyes or clothing. Use personalprotection equipment. |
| 储存Storage | 储藏于阴凉，干燥，通风处，远离接触会发生反应的材料。存储锁定。放在儿童无法接触的地方。 Store in a cool, dry, well-ventilated area away from incompatible substances.Store locked up. Keep out of the reach of children. |
| 其他要注意的防范措施Other Precautions | 万一破裂。按照良好的工业卫生和安全规范进行操作。避免接触皮肤，眼睛或衣服。使用个人防护设备。The battery may explode or cause burns, if disassembled, crushed or exposedto fire or high temperatures. Do not short or install with incorrectpolarity. |
Section 8 - Exposure Controls/Personal Protection
| 工程控制 Engineering Controls | 保证空气流通使空气密度保持在低水平。如果在会生成微粒的情况下使用，应仔细观 察 3mg/m³ ACGIH TLV-TWA的吸入量（总量为 10mg/m³）。 Use adequate ventilation to keep airborne concentrations low. If used under conditions that generate particulates, the ACGIH TLV-TWA of |
| 3mg/m³ respirable fraction (10mg/m³ total) should be observed. 眼睛和脸部保护：消费者无需使用。如果有接触危险：密封安全护目镜。面部防护 罩。 Eye and Face Protection: None required for consumer use. If there is a risk of contact: Tight sealing safety goggles. Face protection shield. | |
| 个人防护设备 Personal Protective Equipment | 皮肤和身体防护：消费者无需使用。如果有接触危险：穿戴防护手套和防护服。 Skin and Body Protection: None required for consumer use. If there is a risk of |
| conditions. If exposure limits are exceeded or irritation is experienced, | contact: Wear protective gloves and protective clothing. 呼吸系统防护：正常使用条件下不需要防护设备。如果超过暴露限值或发生刺激，可 |
| 能需要通风和疏散。 Respiratory Protection: No protective equipment is needed under normal use | |
| ventilation and evacuation may be required. |
第九部分 理化特性
Section 9 - Physical and Chemical Properties
| 物理状态Physical State | 外形：近长方体Appearance: Approximate Cuboid |
| 颜色：蓝色Color: Blue | |
| 气味：泄漏时，医用乙醚的气味。Odour: If leaking, smells of medical ether. | |
| 变化的条件:Change in condition | |
| 酸碱度pH | 不适用。Not applicable as supplied. |
| 熔点/凝固点Melting point/freezing point | 不适用。Not applicable as supplied. |
| 沸点、初沸点和沸程Initial boiling point and boiling range | 不适用。Not applicable as supplied. |
| 闪点Flash Point | 不适用。 1Not applicable as supplied. |
| 爆炸极限Explosion Limits | 不适用。Not applicable as supplied. |
| 蒸气压Vapour pressure | 不适用。Not applicable as supplied. |
| 蒸气密度Vapor density | 不适用。Not applicable as supplied. |
| 密度/相对密度density/Relative density: | 不适用。Not applicable as supplied. |
| 溶解性Solubility | 不适用。Not applicable as supplied. |
| n-辛醇/水分配系数Partition coefficient: n-octanol/water | 不适用。Not applicable as supplied. |
| 自燃温度Auto-ignition temperature | 不适用。Not applicable as supplied. |
| 分解温度Decomposition temperature | 不适用。Not applicable as supplied. |
| 气味阈值Odour threshold | 不适用。Not applicable as supplied. |
| 蒸发速率Evaporation rate | 不适用。Not applicable as supplied. |
| 易燃性(固体、气体)Flammability (solid, gas) | 不适用。Not applicable as supplied. |
Section 10 - Stability and Reactivity
| 化学稳定性Chemical Stability | 稳定的。Stable. |
| 危险反应的可能性Possibility of Hazardous Reactions | 不适用。Not Available. |
| 应避免的条件Conditions to Avoid | 火焰、火花和其他火源，不相容的材料。Flames, sparks, and other sources of ignition,incompatible materials. |
| 不相容材料Incompatible materials | 氧化剂、酸、碱。Oxidizing agents, acid, base. |
| 有危害分解物Hazardous Decomposition Products | 一氧化碳、二氧化碳、氧化锂烟雾。Carbon monoxide, carbon dioxide, lithium oxide fumes. |
第十一部分 毒理学信息
Section 11 - Toxicological Information
第十二部分 生态学信息
Section 11 - Toxicological Information
第十二部分 生态学信息
| 刺激Irritation | 内部物质暴露的情况下，蒸汽烟雾可能对眼睛和皮肤的刺激性。In the event of exposure to internal contents, vapour fumes maybe very irritating to the eyes and skin. |
| 致敏Sensitization | 不适用。Not Available. |
| 再生毒性Reproductive Toxicity | 不适用。Not Available. |
| 协同材料毒理学Toxicologically Synergistic Materials | 不适用。Not Available. |
Section 12 - Ecological Information
第十三部分 废弃处置
Section 13 - Disposal Considerations
第十三部分 废弃处置
Section 13 - Disposal Considerations
| 通用信息： General note: | 不允许未稀释或大量的产品接触地下水、水道或污水处理系统。 Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage system. |
| 化学产品在环境/可能的环境预期的行为 的一种生态毒性 Anticipated behavior of a chemical product in environment/possible environmental impact/ ecotoxicity | 不适用。 Not Available. |
| 废弃处置方法 Waste Treatment | 建议遵照国家和地方法规处置或再利用。 Recycle or dispose of in accordance with government, state & local regulations. |
| 废弃注意事项 Attention for Waste Treatment | 废电池不能被当作普通垃圾。不能扔进火中或置于高温下。不能解体， 刺穿，破碎或类似的处理。最好的处理办法是回收利用。 Deserted batteries couldn't be treated as ordinary trash. Couldn't be thrown into fire or placed in high temperature. Couldn't be dissected, pierced, crushed or treated similarly. Best way is recycling. |
第十四部分 运输信息
Section 14 - Transport Information
| UN编号UN number | UN3480 or UN3481 |
| 运输专用名称Proper shipping name | 锂离子电池（包括锂离子聚合物电池）或Lithium ion batteries (including lithium ion polymer batteries) or与设备包装在一起的锂离子电池（包括锂离子聚合物电池）或Lithium ion batteries packed with equipment (including lithium ionpolymer batteries) or 1内置在设备中的锂离子电池（包括锂离子聚合物电池）Lithium ion batteries contained in equipment (including lithium ionpolymer batteries) |
| 危险货物类别Class or division | 9 |
| 海洋污染物（是/否）Marine pollutant (Yes/No) | 否No |
| 包装等级Packing group | |
| 备注Comment | 包装必须达到Ⅱ级包装的性能标准Packagings must meet packing group Il performance standard |
| 无论是对内还是对外的运输或运输方式，用户都需要注意或遵守的特殊预防措施。Special precautions which a user needs to be aware of, or needs to comply with, in connection withtransport or conveyance either within or outside their premises | |
| 国际民间航空组织/国际航空运输协会：ICAO / IATA: | 货物可根据民用航空组织(ICAO)，TI或国际航空运输协会(IATA)，DGR67th(2026版)包装说明(PI)965 Section IA或PI 966 Section I 或PI 967SectionI相关规定进行空运。Can be shipped by air in accordance with International Civil AviationOrganization (ICAO), TI or International Air Transport Association(IATA), DGR Packing Instructions (PI) 965 Section IA, or (PI) 966Section I, or (PI) 967 Section I appropriate of IATA DGR 67th (2026Edition) for transportation. |
| 国际海运危险货物规则：IMDG CODE: | 该电池受IMDG Code 2024 版(Amdt 42-24)限制,包装说明P903.Can be shipped by sea in accordance with IMDG Code 2024 Edition(Amdt 42-24)Packing Instructions P903. |
| 《危险物品规则》 | |
| a) | Dangerous Goods Regulations |
| b) 联合国《关于危险货物运输的建议书规章范本》 | |
| Recommendations on the Transport of Dangerous Goods-Model Regulations | |
| c) 联合国《关于危险货物运输的建议书试验和标准手册》 Recommendations on the Transport of Dangerous Goods-Manual of Tests and Criteria | |
| d) | 《国际航空运输协会》（IATA） |
| International Air Transport Association (IATA) | |
| e) | 《国际海运危险货物规则》 (IMDG) |
| International Maritime Dangerous Goods (IMDG) | |
| f) | 《危险货物安全运输技术指南》 Technical Instructions for the Safe Transport of Dangerous Goods |
| g) | 《危险货物分类和品名编号》- GB6944-2012 |
| Classification and code of dangerous goods (GB 6944-2012) | |
| h)2012《职业安全与健康标准》危险通信标准（29 CFR 1910.1200） | |
| 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200) | |
| i) | 《有毒物质控制法》（TSCA） |
| Toxic Substance Control Act (TSCA) | |
| j) | 《联邦条例》 |
| Code of Federal Regulations | |
| k) 符合所有联邦、州和地方法律 | |
| In accordance with all Federal, State and local laws |
| 国际道路运输危险货物协定/ 国际铁路运输危险货物规则： ADR/ RID: | 可根据ADR 2025/RID 2025 相关规定进行运输。 Shipping may be done in accordance with the ADR 2025 / RID 2025. |
| 此外，每个锂电池和电池组类型都必须通过联合国《关于危险货物运输的建议书试验和标准手册》第38.3 节规定的适用测试 In addition, to be permitted in transport each lithium cell and battery types must have passed the applicable tests set out in Subsection 38.3 of the UN Manual of Tests and Criteria. | |
第十五部分 法规信息
Section 15 - Regulatory Information
第十六部分 其他信息
Section 16 - Other Information
本份 MSDS 中的信息只是基于我们当前所拥有的相关材料的信息而编制的，只是为了描述本品的健康、安全与环境需求，以使各有关方面能更好地了解和信任本产品。这些信息只是提供给您，以供考虑、研究和确认。其中的一些危害预防措施描述并非是唯一的。所以本份 MSDS 不能作为使用本品实现任何特定目的的保证。各有关使用者有责任预先完成本品的安全性及其他方面的测试，以评判其是否满足您的使用目的。To the best of our knowledge, the information contained herein is accurate. However, neither the abovenamed supplier nor any of its subsidiaries assumes any liability whatsoever for the accuracy ocompleteness of the information contained herein. Final determination of suitability of any material is the soleresponsibility of the user. All materials may present unknown hazards and should be used with caution.Although certain hazards are described herein, we cannot guarantee that these are the only hazards that
exist.
本文所包含的数据/信息已经过审核和批准，但本文档不包含出口管制信息。
The data/information contained herein has been reviewed and approved for general release on the basis that this document contains no export controlled information.
样品图片：
Sample photo:
MSDS 报告
MSDS Report
| 申请商：Prepared For: | 深圳市博贝斯科技有限公司Shenzhen Bobes Technology Co., Ltd | ||
| 地址：Address: | 深圳市龙华区大浪街道华盛路134号雍景轩商业大厦1448室Room 1448, Yongjingxuan Commercial Building, 134 Huasheng Road,DalangStreet, Longhua District, Shenzhen, China | ||
| 产品名称：Product Name: | 可充电锂离子电池组Rechargeable lithium-ion battery Pack | ||
| 型号：Model: | BBS 2410-1 | ||
| 参数：Parameters: | 24V, 10Ah, 240Wh | ||
| 质量：Weight: | Approx(约). 1.6kg | ||
| 尺寸：Dimension: | 155.0mm×134.0mm×42.0mm(T×W×L) | ||
| 编制单位：Prepared By: | 深圳诚测检测技术有限公司Shenzhen CCJC Technology Co.,Ltd.广东省深圳市宝安区松岗街道溪头社区溪头路25号厂房101（1-3层）1-3/F., Factory Building 101, No.25, Xitou Road, Xitou, Songgang Subdistrict,Bao'an District, Shenzhen, Guangdong, China | ||
| 报告编号：Report No.: | CCJC2023A780605 | 接收日期：Accepted date: | 2025-12-16 |
| 检验日期：Inspection Date: | 2025-12-20 | 生效日期：Effective Date | 2026-01-01 |
| 李远勇 Li Yuan Yong 段 Roc cheng主检人：批准人：Tested by: 李远勇 Li Yuan Yong Approved by: 程鹏 Roc Cheng职位 Position: 测试工程师 Test Engineer 职位 Position: 技术负责人 Technical Manager钟庭芝Tosha 2hong审核人： 签发日期：Inspected by: 2025-12-20钟庭芝 Tosha Zhong Date of Issue:职位 Position: 项目工程师 Project Engineer | |||
Material Safety Data Sheet
第一部分 化学品及企业标识
Section 1 - Chemical Product and Company Identification
第二部分 危险性概述
第二部分 危险性概述
| 产品名称：Product Name: | 可充电锂离子电池组Rechargeable lithium-ion battery Pack |
| 产品型号Product Model: | BBS 2410-1 |
| 制造商：Manufacturer: | 东莞市博贝斯新能源科技有限公司Dongguan Bobes New Energy Technology Co., Ltd. |
| 地址：Address: | 广东省东莞市横沥镇新四黄塘路89号3号楼301室3nd Floor, Building D, Guangdong Huayuzhi Industrial Park, 89 Huangtang Road,Hengli Town, Dongguan City, China |
| 电话：Tel: | +86-769-88086182 |
| 传真：Fax: | / |
| 应急电话：Emergency Tel: | |
| 邮箱：E-mail: | 583703908@qq.com |
Section 2 - Hazards Identification
| 危险性类别Classification ofDanger | 见第十四部分。See section 14. |
| 浸入途径Primary Route(s)of Exposure | 眼睛，皮肤接触，摄入。Eye, skin contact, ingestion. |
| 健康危害Health Hazard | 正常条件下根据制造商的说明使用电池不会产生危害。使用不当的情况下，有破裂、起火、发烫、内部成分泄漏的危险，并可能造成意外损失。使用不当的行为包括但不限于下列情况：长时间充电、短路、投入火中、硬物撞击、尖物刺破、破碎，和破裂。The batteries are not hazardous when used according to the instructions ofmanufacturer under normal conditions. In case of abuse, there's risk of rupture,fire, heat, leakage of internal components, with could cause casualty loss.Abuses include but not limited to the following cases: charged for long time,short circuited, put into fire, whacked with hard object, punctured with acuteobject, crushed, and broken. |
| 化学名称Chemical Composition | CAS 编号CAS No. | 浓度或浓度范围(%)Concentration orconcentration ranges (%) |
| 镍酸锂Lithium nickel oxide | 12031-65-1 | 16.0 |
| 钴酸锂Lithium cobaltate | 12190-79-3 | 6.4 |
| 锰酸锂Lithium Manganate | 12057-17-9 | 9.6 |
| 石墨Graphite | 7782-42-5 | 17.0 |
| 六氟磷酸锂Lithium Hexafluorophosphate | 21324-40-3 | 2.0 |
| 碳酸乙烯酯Ethylene Carbonate(EC) | 96-49-1 | 4.0 |
| 碳酸甲乙酯Ethyl Methyl Carbonate | 623-53-0 | 7.0 |
| 碳酸丙烯酯Propylene Carbonate(PC) | 108-32-7 | 1.0 |
| 镍Nickel | 7440-02-0 | 2.0 |
| 铝Aluminium | 7429-90-5 | 12.0 |
| 铜Copper | 7440-50-8 | 8.0 |
| 碳Carbon | 7440-44-0 | 2.0 |
| 聚偏氟乙烯PolyvinylideneFluoride(PVD | 24937-79-9 | 4.0 |
| 聚乙烯Polyethlyene(PE) | 9002-88-4 | 3.0 |
| 聚对苯二甲酸乙二醇酯树脂poly(ethylene terephthalate) | 25038-59-9 | 6.0 |
标签根据EC指令。
Labeling according to EC directives.
不需要象形符号和危险短语。
No symbol and risk phrase are required.
注意: CAS 号是化学文摘服务注册号码。
Note: CAS number is Chemical Abstract Service Registry Number.
N/A =不适用。
N/A=Not apply.
第四部分 急救措施
第五部分 消防措施
第五部分 消防措施
| 眼睛Eye | 万一接触，立即用大量的清水冲洗至少15分钟，翻起上下眼睑，直到化学的残留物消失为止，迅速就医。Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper andlower eyelids. Get medical aid. |
| 皮肤Skin | 万一接触，用大量水冲洗至少15分钟，同时除去污染的衣物和鞋子，迅速就医。Remove contaminated clothes and rinse skin with plenty of water or shower for 15minutes. Get medical aid. |
| 吸入Inhalation | 立即从暴露处移至空气清新处，如果呼吸困难给予输氧，立即就医。Remove from exposure and move to fresh air immediately. Use oxygen if available. |
| 食入Ingestion | 饮用至少两杯牛奶或水。如果当事人仍然清醒可以采取催吐的方法，并且立即就医。Give at least 2 glasses of milk or water. Induce vomiting unless patient is unconscious.Call a physician. |
Section 5 - Fire Fighting Measures
第六部分 泄露应急处理
第六部分 泄露应急处理
| 危险特性Characteristics of Hazard | 高密度粉尘遇空气会形成爆炸性混合物。燃烧生成有毒烟雾。Dusts at sufficient concentrations can form explosive mixtures with air.Combustion generates toxic fumes. |
| 燃烧产生的危险物品Hazardous CombustionProducts | 二氧化碳。Carbon dioxide. |
| 灭火方法及灭火剂Fire-extinguishing Methodsand Extinguishing Media | 对于小型火险，可使用水枪，干冰（也就是液态二氧化碳）或化学泡沫。For small fires, use water spray, dry chemical, carbon dioxide orchemical foam. |
| 灭火注意事项Attention in Fire-extinguishing | 因为压强关系，要穿戴可呼吸式全身防护装备，MSHA/NIOSH（经认证或等效的），以及佩戴全套防护装置。Wear self-contained breathing apparatus in pressure-demand,MSHA/NIOSH (approved or equivalent) and full protective gear. |
Section 6 - Accidental Release Measures
| 个人预防措施、防护装备和 应急程序 Personal Precautions, protective equipment, and emergency procedures | 万一破裂。注意！腐蚀性物质。避免接触皮肤，眼睛或衣服。确保空气流 通。根据需要使用个人防护装备。将人员撤离到安全区域。让人们远离溢出/ 泄漏处和处于逆风。参考第七部分和第八部分中列出的防护措施。 In case of rupture. Attention! Corrosive material. Avoid contact with skin, eyes and clothing. Ensure adequate ventilation. Use personal protective equipment as required. Evacuate personnel to safe areas. Keep people away from and upwind of spill/leak. Refer to protective measures listed in Sections 7 and 8. |
| 环境保护措施 Environmental Precautions | 防止产品污染土壤和进入下水道或水道。 Prevent product from contaminating soil and from entering sewers or waterways. |
| 方法和材料控制 Methods and materials for Containment | 出于安全，阻止泄漏，可以用干砂或泥土来遏制液体溢出，立即清理溢出 物。 Stop the leak if safe to do so. Contain the spilled liquid with dry sand or earth. Clean up spills immediately. |
| 清理的方法和材料 Methods and materials for cleaning up | 用惰性吸收剂(干砂或泥土)吸收溢出的材料。污染物转移到可接受的废物容 器中。收集所有受污染的吸收剂，按照第十三部分的说明进行处理。用洗涤 剂和水清洁污染区域，收集所有受污染的洗涤水，妥善处理。 Absorb spilled material with an inert absorbent (dry sand or earth). Scoop contaminated absorbent into an acceptable waste container. Collect all contaminated absorbent and dispose of according to directions in Section 13. Scrub the area with detergent and water; collect all contaminated wash water for proper disposal. |
第七部分 操作处置与储存
Section 7 - Handling and Storage
第八部分 接触控制和个体防护
第八部分 接触控制和个体防护
| 操作Handling | 拆解、挤压、直接放入火中或高温条件下，电池可能发生爆炸和燃烧。禁止短路或将电池正负极错误的安装在设备中。In case of rupture. Handle in accordance with good industrial hygiene andsafety practice. Avoid contact with skin, eyes or clothing. Use personalprotection equipment. |
| 储存Storage | 储藏于阴凉，干燥，通风处，远离接触会发生反应的材料。存储锁定。放在儿童无法接触的地方。 Store in a cool, dry, well-ventilated area away from incompatible substances.Store locked up. Keep out of the reach of children. |
| 其他要注意的防范措施Other Precautions | 万一破裂。按照良好的工业卫生和安全规范进行操作。避免接触皮肤，眼睛或衣服。使用个人防护设备。The battery may explode or cause burns, if disassembled, crushed or exposedto fire or high temperatures. Do not short or install with incorrectpolarity. |
Section 8 - Exposure Controls/Personal Protection
| 工程控制 Engineering Controls | 保证空气流通使空气密度保持在低水平。如果在会生成微粒的情况下使用，应仔细观 察 3mg/m³ ACGIH TLV-TWA的吸入量（总量为 10mg/m³）。 Use adequate ventilation to keep airborne concentrations low. If used under conditions that generate particulates, the ACGIH TLV-TWA of |
| 3mg/m³ respirable fraction (10mg/m³ total) should be observed. 眼睛和脸部保护：消费者无需使用。如果有接触危险：密封安全护目镜。面部防护 罩。 Eye and Face Protection: None required for consumer use. If there is a risk of contact: Tight sealing safety goggles. Face protection shield. | |
| 个人防护设备 Personal Protective Equipment | 皮肤和身体防护：消费者无需使用。如果有接触危险：穿戴防护手套和防护服。 Skin and Body Protection: None required for consumer use. If there is a risk of |
| conditions. If exposure limits are exceeded or irritation is experienced, | contact: Wear protective gloves and protective clothing. 呼吸系统防护：正常使用条件下不需要防护设备。如果超过暴露限值或发生刺激，可 |
| 能需要通风和疏散。 Respiratory Protection: No protective equipment is needed under normal use | |
| ventilation and evacuation may be required. |
第九部分 理化特性
Section 9 - Physical and Chemical Properties
| 物理状态Physical State | 外形：近长方体Appearance: Approximate Cuboid |
| 颜色：蓝色Color: Blue | |
| 气味：泄漏时，医用乙醚的气味。Odour: If leaking, smells of medical ether. | |
| 变化的条件:Change in condition | |
| 酸碱度pH | 不适用。Not applicable as supplied. |
| 熔点/凝固点Melting point/freezing point | 不适用。Not applicable as supplied. |
| 沸点、初沸点和沸程Initial boiling point and boiling range | 不适用。Not applicable as supplied. |
| 闪点Flash Point | 不适用。 1Not applicable as supplied. |
| 爆炸极限Explosion Limits | 不适用。Not applicable as supplied. |
| 蒸气压Vapour pressure | 不适用。Not applicable as supplied. |
| 蒸气密度Vapor density | 不适用。Not applicable as supplied. |
| 密度/相对密度density/Relative density: | 不适用。Not applicable as supplied. |
| 溶解性Solubility | 不适用。Not applicable as supplied. |
| n-辛醇/水分配系数Partition coefficient: n-octanol/water | 不适用。Not applicable as supplied. |
| 自燃温度Auto-ignition temperature | 不适用。Not applicable as supplied. |
| 分解温度Decomposition temperature | 不适用。Not applicable as supplied. |
| 气味阈值Odour threshold | 不适用。Not applicable as supplied. |
| 蒸发速率Evaporation rate | 不适用。Not applicable as supplied. |
| 易燃性(固体、气体)Flammability (solid, gas) | 不适用。Not applicable as supplied. |
Section 10 - Stability and Reactivity
| 化学稳定性Chemical Stability | 稳定的。Stable. |
| 危险反应的可能性Possibility of Hazardous Reactions | 不适用。Not Available. |
| 应避免的条件Conditions to Avoid | 火焰、火花和其他火源，不相容的材料。Flames, sparks, and other sources of ignition,incompatible materials. |
| 不相容材料Incompatible materials | 氧化剂、酸、碱。Oxidizing agents, acid, base. |
| 有危害分解物Hazardous Decomposition Products | 一氧化碳、二氧化碳、氧化锂烟雾。Carbon monoxide, carbon dioxide, lithium oxide fumes. |
第十一部分 毒理学信息
Section 11 - Toxicological Information
第十二部分 生态学信息
Section 11 - Toxicological Information
第十二部分 生态学信息
| 刺激Irritation | 内部物质暴露的情况下，蒸汽烟雾可能对眼睛和皮肤的刺激性。In the event of exposure to internal contents, vapour fumes maybe very irritating to the eyes and skin. |
| 致敏Sensitization | 不适用。Not Available. |
| 再生毒性Reproductive Toxicity | 不适用。Not Available. |
| 协同材料毒理学Toxicologically Synergistic Materials | 不适用。Not Available. |
Section 12 - Ecological Information
第十三部分 废弃处置
Section 13 - Disposal Considerations
第十三部分 废弃处置
Section 13 - Disposal Considerations
| 通用信息： General note: | 不允许未稀释或大量的产品接触地下水、水道或污水处理系统。 Do not allow undiluted product or large quantities of it to reach ground water, water course or sewage system. |
| 化学产品在环境/可能的环境预期的行为 的一种生态毒性 Anticipated behavior of a chemical product in environment/possible environmental impact/ ecotoxicity | 不适用。 Not Available. |
| 废弃处置方法 Waste Treatment | 建议遵照国家和地方法规处置或再利用。 Recycle or dispose of in accordance with government, state & local regulations. |
| 废弃注意事项 Attention for Waste Treatment | 废电池不能被当作普通垃圾。不能扔进火中或置于高温下。不能解体， 刺穿，破碎或类似的处理。最好的处理办法是回收利用。 Deserted batteries couldn't be treated as ordinary trash. Couldn't be thrown into fire or placed in high temperature. Couldn't be dissected, pierced, crushed or treated similarly. Best way is recycling. |
第十四部分 运输信息
Section 14 - Transport Information
| UN编号UN number | UN3556 |
| 运输专用名称Proper shipping name | 车辆，锂离子电池供电Vehicle, lithium ion battery powered |
| 危险货物类别Class or division | 9 |
| 海洋污染物（是/否）Marine pollutant (Yes/No) | 否No |
| 包装等级Packing group | 不适用N/A |
| 无论是对内还是对外的运输或运输方式，用户都需要注意或遵守的特殊预防措施。Special precautions which a user needs to be aware of, or needs to comply with, in connection withtransport or conveyance either within or outside their premises | |
| 国际民间航空组织/国际航空运输协会：ICAO / IATA: | 货物可根据民用航空组织(ICAO)、TI或国际航空运输协会(IATA)、DGR67th (2026版)包装说明(PI) 952相关规定进行空运。Can be shipped by air in accordance with International Civil AviationOrganization (ICAO), TI or International Air Transport Association(IATA), DGR Packing Instructions (PI) 952 appropriate of IATA DGR67th (2026 Edition) for transportation. |
| 国际海运危险货物规则：IMDG CODE: | 货物可根据IMDG Code 2024 版(Amdt 42-24) 包装说明P912相关规定进行海运。Can be shipped by sea in accordance with Packing Instructions P912appropriate of IMDG Code 2024 Edition(Amdt 42-24) for transportation. |
| 国际道路运输危险货物协定/国际铁路运输危险货物规则：ADR/ RID: | 可根据ADR 2025 /RID 2025 相关规定进行运输。Shipping may be done in accordance with the ADR 2025 / RID 2025. |
| 此外，每个锂电池和电池组类型都必须通过联合国《关于危险货物运输的建议书试验和标准手册》第38.3节规定的适用测试In addition, to be permitted in transport each lithium cell and battery types must have passed theapplicable tests set out in Subsection 38.3 of the UN Manual of Tests and Criteria. | |
第十五部分 法规信息
Section 15 - Regulatory Information
a) 《危险物品规则》 Dangerous Goods Regulations
b) 联合国《关于危险货物运输的建议书 规章范本》 Recommendations on the Transport of Dangerous Goods-Model Regulations
c) 联合国《关于危险货物运输的建议书 试验和标准手册》Recommendations on the Transport of Dangerous Goods-Manual of Tests and Criteria
d) 《国际航空运输协会》（IATA）International Air Transport Association (IATA)
e) 《国际海运危险货物规则》（IMDG）International Maritime Dangerous Goods (IMDG)
f) 《危险货物安全运输技术指南》 Technical Instructions for the Safe Transport of Dangerous Goods
g) 《危险货物分类和品名编号》- GB 6944-2012 Classification and code of dangerous goods (GB 6944-2012)
h) 2012《职业安全与健康标准》危险通信标准（29 CFR 1910.1200）2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
i) 《有毒物质控制法》（TSCA）Toxic Substance Control Act (TSCA)
j) 《联邦条例》 Code of Federal Regulations
k) 符合所有联邦、州和地方法律 In accordance with all Federal, State and local laws
第十六部分 其他信息
Section 16 - Other Information
本份 MSDS 中的信息只是基于我们当前所拥有的相关材料的信息而编制的，只是为了描述本品的健康、安全与环境需求，以使各有关方面能更好地了解和信任本产品。这些信息只是提供给您，以供考虑、研究和确认。其中的一些危害预防措施描述并非是唯一的。所以本份 MSDS 不能作为使用本品实现任何特定目的的保证。各有关使用者有责任预先完成本品的安全性及其他方面的测试，以评判其是否满足您的使用目的。
To the best of our knowledge, the information contained herein is accurate. However, neither the above named supplier nor any of its subsidiaries assumes any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards that exist.
本文所包含的数据/信息已经过审核和批准，但本文档不包含出口管制信息。
The data/information contained herein has been reviewed and approved for general release on the basis that this document contains no export controlled information.
样品图片：
Sample photo:
--报告结束-- --End of report--
By Sea
运输危险性鉴别报告书
Identification and Classification Report for Transport of Goods
危险物品 (Dangerous Goods)
报告编号：SEKGZ202511208851WY080001
此报告本年度有效有效期至2026年12月31日
Issued No:
生效日期:2026.01.01
Effective Date:
委托单位： 东莞市博贝斯新能源科技有限公司
Applicant: Dongguan Bobes New Energy Technology Co.,Ltd
物品名称： 可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh
Name of Goods: 240Wh Rechargeable lithium-ion battery Pack BBS 2410-1 24V 10Ah
北京迪捷姆空运技术开发有限公司
Beijing DGM Air Transport Technology Development Co.,Ltd.
报告书使用约定
Terms of the Using of the Report
1. 本公司依据委托人（托运人或其代理人）提供的物品及其运输信息，确定物品的危险性并出具此报告 书。 The report is issued by DGM China according to the information of the goods and the information of its shipping provided by the applicant (shipper or his agent).
2. 依据鉴别的需要，本公司要求委托人提供真实、完整的样品及资料。 According to the demand of identification and classification, DGM China requires the applicant to provide true and exact sample and data of the goods
3. 委托人保证申报的物品和/或提供的样品与交运的货物是同一种物质。 The applicant guarantees that the declared goods and/or the sample who provides should be identical with the contents of cargo that is to be transported.
4. 本公司仅对委托方所提供样品的鉴别结果负责。 DGM China is only responsible for the identification and classification of the sample provided by the applicant.
5. 本报告书经主检员、审核人和批准人签字并加盖本公司印章后生效。 This report will be effective only after it is signed by the inspector:, checker and approver, and stamped by DGM China.
6. 未经本公司书面批准，不得复制本报告书。 The duplicating of this report is prohibited without the written approval of DGM China.
7. 私自转让、复制、盗用、冒用、涂改、或以任何媒体形式篡改的报告书无效。 The report is invalid when anything of the following happens - illegal transfer, reproduce, embezzlement, imposture, modification or tampering in any media form.
8. 报告书仅在本年度内有效。 This report is only valid within the year.
地址：北京首都机场货运北路天竺综合保税区 BGS 货运楼 249 室
邮编：101300
电话：010-69479673
传真：010-69479621
网址：www.dgmchina.com.cn
E-mail: test@dgmchina.com.cn
北京迪捷姆空运技术开发有限公司
| 项目编号Item No. | SEKGZ202511208851 | 签发日期Issued Date | 2025.12.04 | ||
| 鉴别目的Identification Purpose | 是否属于运输危险物品Dangerous Goods or not restricted | 鉴别日期Identification Date | 2025.11.20-2025.12.02 | ||
| 鉴别依据Identification Criteria | IMDG CODE (Amdt 42-24) | ||||
| 物品名称Name ofGoods | 中文名称Name ofChinese | 可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh | |||
| 英文名称Name ofEnglish | Rechargeable lithium-ion battery Pack BBS 2410-1 24V 10Ah 240Wh | ||||
| 生产厂家Manufacturer | 东莞市博贝斯新能源科技有限公司Dongguan Bobes New Energy Technology Co., Ltd. | ||||
| 物品信息Nature of Goods | 该物品为锂离子电池，蓝色，近长方体，尺寸：155.0*134.0*42.0mm。型号/族号：BBS 2410-1每包装件中电池或电芯数量：8块每包装件中的净重：12.8kg每一包装件的毛重：14kg单独包装(注：单块电池的重量约为1.6kg。）The goods are lithium ion batteries,blue,almost cuboid,Size:155.0*134.0*42.0mm.Model/Group:BBS 2410-1Number of batteries or cells per package:8 piecesNet quantity per package:12.8kgGross weight of each package:14kgCells or batteries only | ||||
| 鉴别结论Conclusions | 危险物品(Dangerous Goods) | ||||
| UN 编号(UN No.): | UN3480 | ||||
| 运输专用名称(PSN) | Lithium ion batteries | ||||
| 危险性类别(Class or Div.) | 9 | ||||
| 包装等级(PG) | 1 | ||||
| 备注Comment | 包装必须达到II级包装的性能标准。Packagings must meet Packing Group II performance standard.日 | ||||
| 主检员 审核人 氧蛙 批准人张国梁AppraiserCheckerApprover报告单位（盖章）Stamp | |||||
北京迪捷姆空运技术开发有限公司
| 项目编号 Item No. | SEKGZ202511208851 | |||
| 物品名称 Name of Goods | 中文名称 Name of Chinese | 可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh | ||
| 英文名称 Name of English | Rechargeable lithium-ion battery Pack BBS 2410-1 24V 10Ah 240Wh | |||
| 鉴别项目名称 检验结果 Item | ||||
| 该电池额定瓦特小时数为 240 Wh。 Watt-hour rating of the battery is 240 Wh. 锂电池已通过 UN38.3 测试。 | Inspection Result >100Wh | |||
| Each battery is of a type proved to meet the Requirements of each test in the UN MANUAL OF TESTS AND CRITERIA, Part III,sub-section 38.3. | 符合 Conform | |||
| 电池按照规定的质量管理体系进行制造。 Batteries be manufactured under a quality management programme. | 符合 Conform | |||
| 该锂电池不属于召回电池，不属于废弃和回收电池。 The lithium batteries don't belong to batteries returned to the manufacturer for safety reasons, are not waste lithium batteries and not lithium batteries being shipped for recycling or disposal. | 符合 Conform | |||
| 通过包装件1.2 米跌落试验。 Each package is capable of withstanding a 1.2m drop test in any orientation. | 不适用 Not applicable | |||
| 包装件需要按照特殊规定188的要求进行适当标记。 The package must be appropriately marked according to special provision 188. 每票托运物品均有随附文件说明： | 不适用 Not applicable | |||
| 包装件内装锂离子电池或电芯； 必须小心操作。如包装件破损，有易燃危险性； 包装件破损时应采取的特殊措施，包括检查和必要时的重新包装； 应急电话号码。 Each consignment is accompanied with a document with an indication that: the package contains lithium ion cells or batteries; the package must be handled with care, and that a flammability hazard exists if the package is damaged; special procedures should be followed in the event the package is damaged, to include inspection and | 不适用 Not applicable | |||
| a telephone number for additional information. | ||||
| 注意事项 Remarks conditions and packed in strong outer packagings. | 每一单电池必须做好防短路措施，并装入坚固外包装内。 Each single battery must be packed in such a way as to prevent short circuits under the normal | |||
出单：王义
项目编号：SEKGZ202511208851
物品名称：可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh
锂电池/钠离子电池 UN38.3 试验概要 Test Summary
项目编号：SEKGZ202511208851
项目编号：SEKGZ202511208851
| 单位信息 Company Information | |||||||||||
| 委托单位Consignor | 东莞市博贝斯新能源科技有限公司广东省东莞市横沥镇新四黄塘路89号3号楼301室电话/Tel：0769-88086182 邮箱/Mail：583703908@qq.com | ||||||||||
| 生产单位Manufacturer | 东莞市博贝斯新能源科技有限公司广东省东莞市横沥镇新四黄塘路89号3号楼301室电话/Tel：0769-88086182 邮箱/Mail：583703908@qq.com | ||||||||||
| 测试单位Test Lab | 东莞市中认联科检测技术有限公司广东省东莞市松山湖高新技术产业开发区工业西路18 号锦裕源大厦2号楼D栋电话/Tel:+86-769-26621775 邮箱/Mail:Marketing@zrlklab.com网址/Website: www.zrlklab.com | ||||||||||
| 电池信息Battery Information | |||||||||||
| 名称Name | 可充电锂离子电池组Rechargeable lithium-ionbattery Pack | 电池/电芯类别Battery/Cell Classification | 锂离子电池Li-ion Battery | ||||||||
| 型号Type | BBS 2410-1 | 商标Trademark | 1 | ||||||||
| 额定电压Normal Voltage | 24V | 额定容量Rated Capacity | 10Ah | ||||||||
| 额定能量Watt-hour rating | 240Wh | 外观/Appearance | 蓝色近长方体Approximate BlueCuboid | ||||||||
| 质量/Mass | 1.6kg | 锂含量/Li Content | 不适用 N/A | ||||||||
| 测试信息Test Information | |||||||||||
| 测试报告编号Test Report Number | DSP22080790-2 | 测试报告签发日期Date of Test Report | 2022-09-01 | ||||||||
| 测试标准Edition of UN Manualof Tests and CriteriaUsed | 联合国《试验和标准手册》（第7版）38.3节UN "Manual of Tests and Criteria" ST/SG/AC.10/11/Rev.7/Subsection 38.3 | ||||||||||
| T.1：高度模拟Altitude Simulation | 通过Pass | T.2：温度试验Thermal Test | 通过Pass | T.3：振动Vibration | 通过Pass | ||||||
| T.4：冲击Shock | 通过Pass | T.5：外部短路External Short Circuit | 通过Pass | T.6：撞击/挤压Impact/Crush | 通过Pass | ||||||
| T.7：过度充电Overcharge | 通过Pass | T.8：强制放电Forced Discharge | 通过Pass | 1 | |||||||
| UN38.3.3.1(f)或/orUN38.3.3.2(d) | 不适用 N/A | UN38.3.3.1(g)或/orUN38.3.3.2(e) | 技术珠庭有限公司 | ||||||||
| 签名Signatory职务Title | 出国深、zhang Guueliang检验员 Inspector：张国梁 Zhang Guoliang | 签发日期Issued Date | 07 | ||||||||
中国认可
检验
INSPECTIONCNAS IB0078
航空运输危险性鉴别报告
Identification and Classification Report for Air Transport of Goods
此报告本年度有效有效期至2026年12月31日
报告编号：
PEKGZ202511206089WY760001
Issued No.:
生效日期：2026.01.01
Effective Date:
委托单位： 东莞市博贝斯新能源科技有限公司
Applicant: Dongguan Bobes New Energy Technology Co.,Ltd.
物品名称： 可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh
Name of Goods:Rechargeable lithium-ion battery Pack BBS 2410-1 24V 10Ah 240Wh
北京迪捷姆空运技术开发有限公司
Beijing DGM Air Transport Technology Development Co.,Ltd.
报告书使用约定
Terms of the Using of the Report
1. 本公司依据本年度国际航协《危险品规则》以及委托人（托运人或其代理人）提供的物品及其运输信息，确定物品的航空运输危险性并出具此报告书。
The report is issued by DGM China according to IATA Dangerous Goods Regulations published in the current year and the information of the goods and the information of its shipping provided by the applicant (shipper or his agent).
2. 依据鉴别的需要，本公司要求委托人提供真实、完整的样品及资料。 According to the demand of identification and classification, DGM China requires the applicant to provide true and exact sample and data of the goods.
3. 委托人保证申报的物品和/或提供的样品与交运的货物是同一种物质。 The applicant guarantees that the declared goods and/or the sample who provides should be identical with the contents of cargo that is to be transported.
4. 本公司仅对委托方所提供样品的鉴别结果负责。 DGM China is only responsible for the identification and classification of the sample provided by the applicant.
5. 本报告书经主检员、审核人和批准人签字并加盖本公司印章后生效。
6. 未经本公司书面批准，不得复制本报告书。 The duplicating of this report is prohibited without the written approval of DGM China.
7. 私自转让、复制、盗用、冒用、涂改、或以任何媒体形式篡改的报告书无效。 The report is invalid when anything of the following happens - illegal transfer, reproduce, embezzlement, imposture, modification or tampering in any media form
8. 为适应国际航协《危险品规则》的年度变化，报告书仅在本年度内有效。 This report is only valid within the year in which the IATA Dangerous Goods Regulations is effective.
地址：北京首都国际机场货运北路天竺综合保税区BGS货运楼249室
邮编：101300
电话：010-69479673
传真：010-69479621
网址：www.dgmchina.com.cn
E-mail: test@dgmchina.com.cn
北京迪捷姆空运技术开发有限公司
| 项目编号Item No. | PEKGZ202511206089 | 签发日期Issued Date | 2025.12.04 | |||
| 鉴别目的Identification Purpose | 是否属于航空运输危险物品Dangerous Goods or not restricted | 鉴别日期Identification Date | 2025.12.02 | |||
| 鉴别依据Identification Criteria | IATA DGR 67th, 2026 | |||||
| 物品名称Name ofGoods | 中文Chinese | 可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh | ||||
| 英文English | Rechargeable lithium-ion battery Pack BBS 2410-1 24V 10Ah 240Wh | |||||
| 生产厂家Manufacturer | 东莞市博贝斯新能源科技有限公司Dongguan Bobes New Energy Technology Co., Ltd. | |||||
| 件数Pieces | 托运人或托运人代理人声明本人（本单位）声明：上述运输信息填写真实、准确，鉴别报告已获得委托单位的授权使用，实际运输的货物情况与本鉴别报告一致。如因信息填写错误、实际运输的货物情况与本鉴别报告不一致造成的一切后果，由本人（本单位）承担全部责任，并赔偿对承运人造成的全部损失。托运人或托运人代理人签字： 盖章： | |||||
| 运单号Air waybill No. | ||||||
| 目的港Destination | ||||||
| 物品信息Nature of the goods | 该样品为蓝色近长方体电池。型号: BBS 2410-1尺寸：155.0*134.0*42.0mm每包装件中电池/电芯数量：8每包装件中电池/电芯净重：12.8kg该电池已经做好防短路措施并装入坚固的外包装内。该锂电池不属于召回电池，不属于废弃和回收电池，并按照DGR3.9.2.6.1(e)规定的质量体系进行制造根据委托方所提供的声明：本报告所述锂离子电池（或电芯）交付运输时，其荷电状态不超过设计额定容量的30%。(注：单块电池的重量约为1.6kg。)This sample is blue almost cuboid battery.Model: BBS 2410-1Size: 155.0*134.0*42.0mmNumber of batteries / cells per package: 8Net quantity of batteries/cells per package: 12.8kgBatteries have been protected so as to prevent short circuits and packed in strongrigid outer packagings.The lithium batteries don't belong to batteries returned to the manufacturer forsafety reasons, are not waste lithium batteries and not lithium batteries being shippedfor recycling or disposal, are manufactured under a quality management program asdescribed in 3.9.2.6.1(e).Lithium ion cells and batteries must be offered for transport at a state of charge(SoC)not exceeding 30% of their rated design capacity. | |||||
| 项目编号Item No. | PEKGZ202511206089 | |||||
| 物品名称Name ofGoods | 中文Chinese | 可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh | ||||
| 英文English | Rechargeable lithium-ion battery Pack BBS 2410-1 24V 10Ah 240Wh | |||||
| 鉴别结论Conclusions | 该物品为锂离子/聚合物电池，单独包装。额定瓦特小时为240Wh。已通过UN38.3 测试。参考有关资料，根据DGR有关规定，该物质分类识别为第9类（或项）危险品，UN3480。This goods is lithium ion/polymer battery,packed individually.Watt-hour rating is 240Wh.Eachbattery is of a type proved to meet the Requirements of each test in the UN MANUAL OF TESTS ANDCRITERIA, Part III,sub-section 38.3.According to IATA DGR this substance is classified as dangerous goods Class (or division)9,UN3480. | |||||
| 运输危险性建议SuggestionforTransport | UN/ID 编号UN/ID No. | 运输专用名称Proper Shipping Name | 类或项Class or Div.(次要危险性)(Subsidiary Risk) | 包装等级PackingGroup | ||
| UN3480 | Lithium ion batteries | 9 | 1 | |||
| 包装说明Packing Inst. | 客货机Passenger and Cargo Aircraft | Forbidden | ||||
| 仅限货机Cargo Aircraft only | 965，IA | |||||
| 注意事项Remarks | 包装必须达到II级包装的性能标准Packagings must meet Packing Group II performance | |||||
| 梁蛙主检员审核人张国梁 批准人Prepared by:Checked by:Approved报告单位（盖章） CHINAStamp | ||||||
制单：王义
项目编号：PEKGZ202511206089
物品名称：可充电锂离子电池组 BBS 2410-1 24V 10Ah 240Wh
锂电池/钠离子电池 UN38.3 试验概要 Test Summary
项目编号：PEKGZ202511206089
| 单位信息 Company Information | |||||||||||
| 委托单位Consignor | 东莞市博贝斯新能源科技有限公司广东省东莞市横沥镇新四黄塘路89号3号楼301室电话/Tel：0769-88086182 邮箱/Mail：583703908@qq.com | ||||||||||
| 生产单位Manufacturer | 东莞市博贝斯新能源科技有限公司广东省东莞市横沥镇新四黄塘路89号3号楼301室电话/Tel：0769-88086182 邮箱/Mail:583703908@qq.com | ||||||||||
| 测试单位Test Lab | 东莞市中认联科检测技术有限公司广东省东莞市松山湖高新技术产业开发区工业西路18 号锦裕源大厦2号楼D栋电话/Tel：+86-769-26621775 邮箱/Mail:Marketing@zrlklab.com网址/Website: www.zrlklab.com | ||||||||||
| 电池信息 Battery Information | |||||||||||
| 名称Name | 可充电锂离子电池组Rechargeable lithium-ionbattery Pack | 电池/电芯类别Battery/Cell Classification | 别分类专用锂离子电池Li-ion Battery | ||||||||
| 型号Type | BBS 2410-1 | 商标Trademark | 1 | ||||||||
| 额定电压Normal Voltage | 24V | 额定容量Rated Capacity | 10Ah | ||||||||
| 额定能量Watt-hour rating | 240Wh | 外观/Appearance | 蓝色近长方体Approximate BlueCuboid | ||||||||
| 质量/Mass | 1.6kg | 锂含量/Li Content | 不适用 N/A | ||||||||
| 测试信息 Test Information | |||||||||||
| 测试报告编号Test Report Number | DSP22080790-2 | 测试报告签发日期Date of Test Report | 2022-09-01 | ||||||||
| 测试标准Edition of UN Manualof Tests and CriteriaUsed | 联合国《试验和标准手册》（第7版）38.3节UN "Manual of Tests and Criteria" ST/SG/AC.10/11/Rev.7/Subsection 38.3 | ||||||||||
| T.1：高度模拟Altitude Simulation | 通过Pass | T.2：温度试验Thermal Test | 通过Pass | T.3：振动Vibration | 通过Pass | ||||||
| T.4：冲击Shock | 通过Pass | T.5：外部短路External Short Circuit | 通过Pass | T.6：撞击/挤压Impact/Crush | 通过Pass | ||||||
| T.7： 过度充电Overcharge | 通过Pass | T.8：强制放电Forced Discharge | 通过Pass | 1 | |||||||
| UN38.3.3.1(f)或/orUN38.3.3.2(d) | 不适用 N/A | UN38.3.3.1(g)或/orUN38.3.3.2(e) | |||||||||
| 签名Signatory职务Title | 出国深、zhang Guliong检验员 Inspector：张国梁 Zhang Guoliang | 签发日期Issued Date | 2025-11-2007 | ||||||||
